Home
Thermo King
Automobile Accessories
Precedent C-600M
Thermo King Precedent C-600M User Manual
5
of 1
of 1 rating
166 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Copyright© 2015 T
hermo King Corp., Minn
eapolis, MN, USA
Printed in USA
Precedent
TM
C-600M
Operator
’
s Manual
TK 56169-2-OP (Rev
. 1, 12/15)
2
4
Table of Contents
Table of Contents
5
Introduction
9
EPA Emission Control System Warranty Statement
10
Responsibilities
11
Thermo King Corporation Responsibilities
11
Owner Responsibilities
12
Limitations
12
Safety Precautions
13
General Safety Practices
13
Automatic Start/Stop Operation
13
Electrical Hazard
13
Battery Installation and Cable Routing
14
Refrigerant
15
Refrigerant Oil
15
First Aid
16
First Aid-Refrigerant
16
First Aid-Refrigerant Oil
16
Safety Decals and Locations
16
Condenser and Evaporator Fans
16
High Voltage Components
16
Do Not Use Ether Starting Aids
18
Unit Description
19
Unit Overview
19
Diesel Engine
20
ELC (Extended Life Coolant)
20
Emi 3000
20
Thermo King X430P Reciprocating Compressor
21
Electronic Throttling Valve
21
Remote Evaporators
21
SMART REEFER 4 Multi-Temp (SR-4 MT) Control System
21
Diesel Operation
22
Electric Operation
22
CYCLE-SENTRY Start-Stop Controls
23
Data Logging
23
Optiset Plus
25
Freshset
25
ECO Pulldown Mode
25
Defrost
25
Opening the Front Doors
26
Engine Compartment Components
27
Unit Protection Devices
27
Base Controller Fuses
28
Expansion Module Fuses
28
ECU Interface Board Fuses
28
Battery Fuses
29
Remote Status Display (Optional)
30
Manual Pretrip Inspection
33
(Before Starting the Unit)
33
Operating Instructions
35
SMART REEFER 4 (SR-4 MT) Controller Overview
35
Control Panel
36
Control Panel Display
36
Display Icons
37
Zone Cooling, Heating or Null
38
CYCLE Sentry/Continuous Mode Key
38
ECO-Pulldown Mode
39
Zone Level or Unit Level Alarm Codes
40
Hard Keys
40
Soft Keys
41
Display Heater
42
Turning Unit on and off
42
Two Zone Standard Display
44
Three Zone Standard Display
45
Single Zone Control Standard Display
45
Operating the Unit in Single Zone Mode
46
Temperaturewatch Display
46
Changing the Setpoint
47
Turning a Zone on and off
50
Starting the Diesel Engine
52
Starting the Electric Motor
53
Switching from Diesel to Electric
53
Initiating a Manual Defrost Cycle
56
Terminating a Defrost Cycle
57
Selecting Cycle Sentry or Continuous Mode
59
Using the Main Menu
63
Main Menu Features
64
Pretrip
64
Pretrip Test Conditions
64
Conditions Where Pretrip Tests Are Not Allowed
64
Pretrip Test Considerations
64
Pretrip Test Sequence
65
Performing a Pretrip Test
66
Languages (if Enabled)
72
Available Languages
72
Selecting an Alternate Language
72
Language Menu Quick Access
75
Alarms
77
Log Alarms
77
Check Alarms
77
Unit Level Check Alarms
78
Zone Level Check Alarms
78
Unit Level Prevent Alarms
78
Zone Level Prevent Alarms
79
Shutdown Alarms
79
Unit Level Shutdown Alarms
79
Zone Level Shutdown Alarms
80
Pretrip Alarms
80
Alarm Codes When Switching between Diesel and Electric
80
Clearing Alarm Codes
80
Displaying and Clearing Alarm Codes
82
Important Alarm Notes
84
SR-4 Precedent Alarm Codes
87
Gauges
87
Displaying Gauges
87
Gauges Available
88
Sensors
89
Displaying Sensors
90
Sensors Available
91
Data Logger (Cargowatch)
92
Hourmeters
96
Viewing Hourmeters
96
Hourmeter Names and Definitions
97
Mode
99
Using the Change Mode Menu
99
Turn Cycle Sentry on or off
101
Using the Cycle Sentry Key
101
Using the Main Menu
101
Single Zone Control - Multi Zone Control
103
Select Temperature Units
104
Keypad Lockout
104
Start Sleep Mode
106
Smart Power Electric Standby Option
106
Electric Mode Operation
107
Diesel Mode Operation
107
Switching from Diesel to Electric
107
Electric Standby Power Fails or Is Disconnected
108
Switching from Electric to Diesel
109
Adjust Brightness
110
Time
112
Clear All ECU Faults
113
Loading and Enroute Inspections
116
Pre-Loading Inspection
116
Single Temperature Loading Procedures
118
Post-Loading Inspection
119
Post Trip Checks
119
Inspection Troubleshooting
119
Alarm Codes
122
Introduction
122
Alarm Types
122
Pretrip Alarm Codes
124
Clearing Alarm Codes
125
Jump Starting
145
Warranty
149
Specifications
150
Engine
150
Filters
152
Refrigeration System
152
Electrical Control System
153
Electrical Standby (Smartpower Units Only)
154
Electric Motor and Overload Relay
154
Standby Power Cord Requirements
155
Maintenance Inspection Schedule
156
Serial Number Locations
161
Emergency Cold Line
162
Recover Refrigerant
163
CALIFORNIA Proposition 65 Warning
164
Other manuals for Thermo King Precedent C-600M
Installation Manual
48 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Thermo King Precedent C-600M and is the answer not in the manual?
Ask a question
Thermo King Precedent C-600M Specifications
General
Brand
Thermo King
Model
Precedent C-600M
Category
Automobile Accessories
Language
English
Related product manuals
Thermo King VM-405 PBBD2
112 pages
Thermo King V-300
60 pages
Thermo King V-400
222 pages
Thermo King V-100
60 pages
Thermo King Spectrum
60 pages
Thermo King T- series
68 pages
Thermo King V-520 NM 20
112 pages
Thermo King V220 Series
112 pages
Thermo King V-520 Series
44 pages
Thermo King V-220 Series
84 pages
Thermo King T-1000R Series
175 pages
Thermo King TriPac EVOLUTION
50 pages
Need help?
General
To Next Page
