TigerKing TK12000 - Page 16

16
TigerKing Operating Instructions and Parts Manual
TK12000, TK20000, TK30000, TK50000, TK70000
TigerKing Portable Oil-Fired Heaters
noitcA evitcerroC)s(esuaC elbissoPmotpmyS
- Defective Temper Detective Sensor
- Dirty Air Output, Air Intake or Lint Filter
- Dirty Photocell Lens
- Bad Photocell
- No fuel in tank
- Wrong pump pressure
- Dirty in Nozzle
- Water in Fuel Tank and Dirty Fuel Filter
- Poor electrical connection between ignitor
and Main PCB Assembly
- Ignitor Wire not attached to Spark Plug
- Defective Ignitor
- Thermostat setting too low
- See Pump Pressure Adjustment,
- See Air Output, Air Intake and Lint Filters,
- See Fuel Filter, Pages 10 and 11
- See Nozzle, Page 9
- Clean Photocell Lens, Page 10
- Check electrical components (See wiring
diagrams, Page 13)
- Fill tank with fuel
- Flush Fuel Tank with clean kerosene
- Attach Ignitor Wire to Spark Plug. See
Spark Plug, Pages 9 and 10
- Replace Ignitor
- Turn Thermostat Control Knob to a higher
setting
- Check electrical connections (See wiring
diagrams, Page 13)
Troubleshooting Chart (TK20000,TK30000, TK50000 AND TK70000)
E1
E2
Error fire Frame checking Sensor
Room Temper. detective Sensor Error
- Poor electrical connection between Temper
Detective Sensor and Main PCB
- Replace the Sensor
- Replace photocell
LO
- Temperatur above 50 deg C
- Normal condtion
Hi
Lamp flikering
- Temperature below - 9 deg C
- Power Off
- Error ocuured on working
- Reoperation after reset