Toro Recycler 20017 User Manual

Form No. 3352-565 Rev A
22" Recycler ®
Lawn Mower
Model No. 20017mSerial No. 250000001 and Up
Operator's Manual
introduction
Read this manual carefully to learn how to operate
and maintain your product properly and to avoid injury
and product damage. You are responsible for
operating the product properly and safely.
You may contact Toro directly at www.Toro.com for
product and accessory information, help finding a
dealer, or to register your product.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model
and serial numbers of your product ready. The
illustrationbelow identifies the location of the model
and serial numbers on the product. Write the numbers
in the space provided below:
Model #:
Serial #:
m-5607
This manual identifies potential hazards and has
safety messages identified by the following words:
• Danger signals an extreme hazard that will
cause serious injury or death if you do not follow
the recommended precautions.
• Warning signals a hazard that may cause
serious injuryor death ifyou do not follow the
recommended precautions.
• Caution signals a hazard that may cause minor
or moderate injury if you do not follow the
recommended precautions.
This manual uses two other words to highlight
information. Important: calls attention to special
mechanical information and Note: emphasizes
general information worthy of special attention.
The engine exhaust from this product contains
chemicals known to the State of California to
cause cancer, birth defects, or other reproductive
harm.
Important: This engine is not equipped with a spark
arrester muffler. It is a violation of California Public
Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered or
grass-covered land. Other states or federal areas
may have similar laws.
This spark ignitionsystem complies with Canadian
ICES-002.
The enclosed Engine Owner's Manual is supplied for
information regarding The U.S. Environmental
Protection Agency (EPA) and the California Emission
Control Regulation of emission systems, maintenance
and warranty. Replacements may be ordered through
the engine manufacturer.
The engine manufacturer has specified the rated
engine gross horsepower based on SAE
standards/procedures (J1940 and J1995). As
configured to meet safety, emission, and operating
requirements, the actual engine horsepower on this
class of lawn mower will be significantly lower. Do not
tamper with the engine controls or alter the governor
speed; doing so may create an unsafe condition
resulting in personal injury.
Safety
This lawn mower meets or exceeds the CPSC blade
safety requirements for walk-behind rotary lawn
mowers and the B71.1 specifications of the American
National Standards Institute in effect at the time of
production.
Read and understand the contents of this manual
before the engine is ever started.
Z_ This is the safety alert symbol, it is used to
alert you to potential personal injury hazards.
Obey all safety messages that follow this symbol
to avoid possible injury or death.
Improperly using or maintaining this mower
could result in injury or death. To reduce this
potentiam,comply with the following safety
instructions.
The following instructions have been adapted from
the ANSI/OPEl standard B71.1--2003.
This cutting machine is capable of amputating hands
and feet and throwing objects. Failure to observe the
following safety instructionscould result in serious
injury or death.
(© 2005--TheToro Company Printed in the USA Original Instructions (EN)
8111 Lyndale Ave., IBIoomington, MN 55420, USA All Rights Reserved Register your product at www.Toro.com

Toro Recycler 20017 Specifications

General

Cutting Width	21 inches
Mulching Capability	Yes
Bagging Capability	Yes
Side Discharge	Yes
Engine Displacement	190cc
Deck Material	Steel
Starter Type	Recoil
Warranty	2-Year Full
Engine	Briggs & Stratton
Wheel Size	8 in (front), 8 in (rear)

Summary

Introduction to Toro Lawn Mower

Product Information and Contact

Provides contact information for Toro, product details, and how to find model/serial numbers.

Safety Precautions

Slope Operation Safety

Details safe practices for operating the mower on slopes to prevent accidents and injuries.

Children Safety Measures

Emphasizes the importance of keeping children away from the mower and ensuring their safety.

General Operation Guidelines

Safe Mowing Practices

Outlines essential rules for safe operation, including clearing the area and bystander safety.

Service and Safety Decals

General Service Information

Covers general maintenance, cleaning, and ensuring the equipment is in safe working condition.

Safety and Instruction Decals

Highlights the location and importance of safety decals for hazard awareness.

Product Overview and Setup

Mower Components Identification

Identifies and labels the main parts of the Toro lawn mower.

Handle Setup Procedure

Provides steps for unfolding and securing the mower handle, warning about cable damage.

Pre-Operation Checks

Filling Engine with Oil

Instructs on checking and adding engine oil, specifying type, level, and capacity.

Fuel Tank Filling

Guides on safely refueling the mower, including indoor warnings and fuel stabilizer use.

Checking Engine Oil Level

Details the procedure for verifying the engine oil level using the dipstick.

Adjusting Mower Settings

Adjusting Cutting Height

Explains how to set the desired grass cutting height by adjusting the wheel levers.

Adjusting Handle Height

Describes how to change the handle position by moving it to different mounting holes.

Mower Operation

Starting the Engine

Step-by-step guide to priming and starting the mower engine using the recoil starter.

Using Self-Propel Drive

Explains how to engage and use the self-propel feature for easier mowing.

Stopping the Engine

Details the correct procedure for safely stopping the engine and blade.

Clipping Management Options

Recycling Grass Clippings

Instructions on how to prepare the mower for recycling clippings back into the lawn.

Bagging Grass Clippings

Guides on installing the grass bag to collect clippings effectively.

Cutting Grass Techniques

Side Discharging Clippings

Instructions on using the side discharge for cutting tall grass and related setup.

General Cutting Tips

Provides advice on mowing techniques, blade condition, and grass length for optimal results.

Wet Grass Warning

Warns against mowing wet grass due to slip hazards and potential mower plugging.

Maintenance and Leaf Cutting

Cutting Thick Leaf Layers

Advice on adjusting mower settings for effectively cutting and dispersing leaf layers.

Maintenance Schedule

Outlines a recommended schedule for regular maintenance tasks based on usage.

Preparing for Maintenance Tasks

Details essential safety steps, like disconnecting the spark plug, before performing maintenance.

Specific Maintenance Tasks

Replacing Air Filter

Step-by-step guide for replacing the air filter to ensure proper engine function.

Lubricating Wheel Gears

Instructions for applying lubricant to the rear wheel gears for smooth operation.

Changing Engine Oil

Detailed procedure for draining and refilling the engine oil, including disposal.

Blade Service and Mower Cleaning

Replacing the Mower Blade

Comprehensive guide on replacing the blade, including safety, tools, and torque specifications.

Cleaning the Mower Housing

Method for cleaning grass clippings from under the mower housing using water and engine run.

Storage and Handle Folding

Preparing Mower for Storage

Steps to prepare the mower for long-term storage, focusing on fuel and engine preservation.

Folding and Unfolding Handle

Instructions for safely folding and unfolding the mower handle for storage or transport.

Removing Mower from Storage

Steps to take when preparing the mower for use after a period of storage.

Toro Warranty Information

Total Coverage Guarantee Details

Explains the comprehensive warranty covering defects in materials and workmanship for Toro products.

Starting Guarantee Terms

Outlines the 'Guaranteed to Start' engine warranty, covering starting issues for two years.

Commercial Use Warranty Limitations

Specifies the shorter warranty period and exclusions for commercial use of the mower.

Warranty Exclusions and Owner Duties

Lists conditions not covered by warranty and the owner's responsibilities for maintenance and service.