Toshiba RAS-10PKVP-ND Service Manual (English)

Other manuals for Toshiba RAS-10PKVP-ND

Owner's Manual32 pages

Installation Manual26 pages

Questions and Answers:

R
rgravesAug 7, 2025
What to do if my Toshiba Air Conditioner is not turning on?
- C
  Chad ZimmermanAug 7, 2025
  If your Toshiba Air Conditioner is inoperative, there are several possible reasons. First, ensure that the main power switch is turned on. Also, check if the circuit breaker has been activated, cutting off the power supply, and reset it if necessary. Examine the main power fuse and replace it if it has blown. Verify that there is an electric current. Replace the batteries in the remote controller. If the ON timer is set, disable it. Finally, remember that as a protective measure, the air conditioner may not operate for 3 minutes after restarting or turning on the main power; wait for 3 minutes and try again.
C
cjonesAug 16, 2025
Why is my Toshiba RAS-10PKVP-ND not cooling properly?
- M
  melvinmacdonaldAug 17, 2025
  If your Toshiba Air Conditioner isn't cooling effectively, several factors could be responsible. Check that the air inlet or outlet of the outdoor unit isn't blocked. Ensure all doors and windows are closed. A clogged air filter can also reduce performance, so clean it. Make sure the louver is correctly positioned. Check that the fan speed isn't set too low, and adjust it as needed. The air conditioner might be in DRY or SLEEP mode, so switch to a more suitable setting. If you are in cooling operation, the temperature setting might be too high, so lower it. Finally, ensure that the air conditioner is being used within its specified operating conditions. If none of these steps work, remove the cause of the problem, and after about 30 seconds, turn on the circuit breaker again.
T
Tony ParkerAug 27, 2025
What to do if my Toshiba RAS-10PKVP-ND Air Conditioner is not heating properly?
- R
  Robert FullerAug 27, 2025
  If your Toshiba Air Conditioner isn't heating effectively, several factors could be responsible. Check that the air inlet or outlet of the outdoor unit isn't blocked. Ensure all doors and windows are closed. A clogged air filter can also reduce performance, so clean it. Make sure the louver is correctly positioned. Check that the fan speed isn't set too low, and adjust it as needed. The air conditioner might be in DRY or SLEEP mode, so switch to a more suitable setting. If you are in heating operation, the temperature setting might be too low, so increase it. Finally, ensure that the air conditioner is being used within its specified operating conditions. If none of these steps work, remove the cause of the problem, and after about 30 seconds, turn on the circuit breaker again.

Toshiba RAS-10PKVP-ND Specifications

General

Brand	Toshiba
Model	RAS-10PKVP-ND
Category	Air Conditioner
Language	English

Summary

Safety Precautions

Specifications

Detailed Unit Specifications

Provides detailed technical specifications for cooling/heating capacity, power, and noise.

Operation Characteristic Curves

Shows current vs. compressor speed curves for cooling and heating operations.

Capacity Variation by Temperature

Illustrates how cooling and heating capacity changes with outdoor temperature.

Refrigerant R410A

R410A Safety Precautions

Critical safety information for handling R410A refrigerant during installation and servicing.

Refrigerant Piping Installation Guide

Covers piping materials, joints, and processing requirements for R410A systems.

Required Installation and Service Tools

Lists specialized tools needed for R410A installation and service.

Refrigerant Recharging Procedure

Step-by-step instructions for safely recharging refrigerant into the system.

Pipe Brazing Procedures and Materials

Details materials, flux, and proper brazing techniques for pipe connections.

Construction Views

Indoor Unit Construction Diagram

Exploded view showing the physical components and dimensions of the indoor unit.

Outdoor Unit Construction Diagram

Exploded view illustrating the physical components and dimensions of the outdoor unit.

Wiring Diagram

Specifications of Electrical Parts

Indoor Unit Electrical Parts Specs

Lists electrical components and their specifications for the indoor unit.

Outdoor Unit Electrical Parts Specs

Lists electrical components and their specifications for the outdoor unit.

Refrigerant Cycle Diagram

Refrigerant Cycle Diagram Overview

Illustrates the flow of refrigerant through the indoor and outdoor units.

Cooling and Heating Operation Data

Provides operational data like pressure, temperature, and fan/compressor speeds for different conditions.

Control Block Diagram

Indoor Unit Control Block Diagram

Shows the control flow and interconnections within the indoor unit.

Outdoor Unit Control Block Diagram

Illustrates the control logic and components of the outdoor unit's inverter assembly.

Operation Description

Air Conditioner Control Overview

Explains overall control structure and components like DC motors and VCM compressor.

Basic Operation Modes

Covers Cooling, Heating, AUTO, and DRY operation controls and logic.

Fan Motor Control Details

Details indoor and outdoor fan motor speed control logic in various modes.

Capacity and Protective Controls

Explains capacity adjustment, current release, and heat exchanger protective controls.

Special Operating Modes

Covers Defrost, SLEEP MODE, Air Purifying, Clean Operation, and Hi POWER modes.

Remote Controller Functions

Details remote controller operation, settings, and indicators.

Unit Setup and Maintenance

Covers temperature correction, quiet control, auto restart, and remote controller selection.

Installation Procedure

Unit Installation Diagram

Provides visual guide for unit placement and connections.

Installation Parts and Tools

Lists required optional parts, accessories, and specialized tools for installation.

Indoor Unit Installation Steps

Details location selection, drilling, wiring, piping, drainage, and mounting steps for the indoor unit.

Outdoor Unit Installation Steps

Covers outdoor unit location, precautions for cold climates, water draining, and refrigerant piping.

Test Operation and Settings

Procedures for gas leak testing, system test operation, and auto restart function setup.

Main Part Removal Procedures

Step-by-step guide for disassembling and removing major indoor unit components.

Troubleshooting

Inverter Handling Precautions

Safety guidelines for working with inverter components, highlighting high voltage risks.

Initial Fault Diagnosis Methods

Methods for initial fault diagnosis using LED indicators, self-diagnosis, and symptom analysis.

Indoor Unit LED Flash Code Diagnosis

Interpreting indoor unit LED flash codes for self-diagnosis and identifying fault locations.

Remote Controller Self-Diagnosis (Check Codes)

Using the remote controller to access and interpret diagnostic check codes for troubleshooting.

Troubleshooting by Symptom

Step-by-step troubleshooting guides for common symptoms like no power or fan issues.

Check Codes 1C & 1E Troubleshooting

Specific troubleshooting steps for miswiring and gas leakage related check codes.

Outdoor Unit Troubleshooting Guide

Troubleshooting flowchart and checks for outdoor unit components like fan motor and compressor.

Main Component Inspection Procedures

Detailed inspection procedures for P.C. boards, sensors, motors, and other key components.

Replacing the Main Parts

Indoor Unit Component Replacement

Procedures for replacing indoor unit parts like panels, motors, heat exchangers, and boards.

Plasma Ion Charger Replacement

Steps for common procedures, protective board, and high-voltage unit replacement.

Outdoor Unit Component Replacement

Procedures for replacing outdoor unit parts like cabinets, motors, compressor, sensors, and boards.

Exploded Views and Parts List

Indoor Unit Exploded View and Parts List

Exploded view illustration and list of all indoor unit parts with their part numbers.

Microcomputer P.C. Board Parts List

Lists part numbers for various microcomputer P.C. boards used in the unit.

Outdoor Unit Exploded View and Parts List

Exploded view illustration and list of all outdoor unit parts with their part numbers.

Related product manuals

Toshiba RAS-10PKVPG-E

17 pages

Toshiba RAS-10PKVSG-E

148 pages

Toshiba RAS-10PAVP-ND

32 pages

Toshiba RAS-10PAVSG-E