Trane Airfinity XL IC140 - Page 53

54 pages

To Next Page

To Previous Page

Main Page

Table of Contents2
General Information4
Foreword4
Warnings and Cautions4
Power Supply Safety Recommendations4
Capacities Cooling Capacity on Water4
Reception4
Loose Parts Inventory4
(V/Ph/Hz)4
Fan Motor Warranty4
Refrigerant4
Start-Up Amps Maintenance Contract5
Training5
Sound Pressure Level5
Unit Model Number Description6
IC General Data8
Fwd8
FWD 10 Operation10
ISO R7 Rotating Female12
IH General Data12
Electric Heater (Accessory for Blower Only)12
Fwd12
Fwd14
Unit Operating Principle16
Electric Power Supply18
Heating Capacity18
(V/Ph/Hz)18
Installation18
Hot Water Coil (Accessory for Blower Only)18
(Kw) G2 Filter (Filter Box Accessory) Reception of Units18
Dimensions ( Lxwxth)18
G4 Filter (Filter Box Accessory)18
Roof Curb Installation18
Installing the Unit19
(MM) 386X221X820
Dimensions ( Lxwxth)20
Condensate Pump (Accessory)20
Sound Level (L/M/H Speed)20
Fwd20
Centrifugal Water Flow - Lift Height Connection of Duct Network21
Dimensions/Weights and Clearance21
Condensate Drain Piping21
(MM) - 486X264X48 586X314X4822
Filter Installation22
Unit Dimensions22
Shipped Unit Dimensions Width X Depth22
Recommended Fuse Size22
Supply Plug Fan Airflow Adjustment22
(MM) Height Refrigerant Leak Detector R454B23
Supply Fan Airflow Measurement Option23
Gas Pipework Installation24
Smoke Outlet Features24
General Electrical Recommendations25
Installer-Supplied Components25
Electrical Connections25
Blink Code for Motor Protector with Status LED26
230V),3*16 (400V)26
Energy Recovery Module Installation27
HRW Module Preparation29
HRW Module Installation30
Fresh Air Hood Installation32
Fwd 0833
Operating Map35
Accessories - Hot Water Coil: Cooling Mode35
Water Temperature: Min. +2° C/Max. 100° C36
Absolute Service Pressure: Min 1 Bar/Max 11 Bars36
Heating Mode36
Options37
Fresh Air Hood Installation37
Building Pressurization Control37
Barometric Relief37
Exhaust Fans38
Operation38
Hot Water Coil (HWC)39
Electric Heater40
Burner Module40
Assembly Procedure of Fan Block40
Controls41
CH536 + Module Extension41
Control Hardware Modules41
Control Hardware Bus41
Sound Power Levels Service Terminal41
Zone Temperature Source42
Discharge CO 2 Sensor42
CO 2 Sensor Maintenance42
Measurement Conditions: Fire Thermostat42
Measurements Taken in a Room Adjacent to the Room Containing the FWD, at the Outlet of the Rectangular Duct42
Smoke Detector42
Other Accessories Available42
Unit Alarm and Warnings42
Customer Option Module44
Operation with a Conventional Thermostat44
Power Level in Db(A), Per Hz Frequency Band45
Overall Power45
Test Procedures46
Power-Up Initialization46
Operating Pressures46
Gas Burner First Start47
Interface Panel47
Maintenance48
End User Routine Maintenance48
Air Filters48
Intake Condenser Coil48
Hot Water Coil (Option)48
Service Technician Maintenance48
Troubleshooting Alarm and Warnings48
Refrigerant Leak Detector R454B Calibration49
Recommended Service Routine Frequencies50
Commissioning51
Gas Heat51
Electric Heat51
Hot Water/Steam51
500/1000 Hours Visit51
Inspection Visit51
Annual Maintenance51
Refrigerant Leak Detector R454B51
Additional Services52
Oil Analysis52
Refrigerant Analysis52
Trane Select Agreements52
Years Motor-Compressor Warranty52
Energy Enhancement52

Trane Airfinity XL IC140 - Page 53

Table of Contents

Related product manuals