Home
Trane
Air Conditioner
TSC037E
Trane TSC037E User Manual
5
of 1
of 1 rating
68 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Unit
Dimensions
RT
-SVX22M-EN
15
Figur
e
2.
3-5
ton
standard
efficiency
,
3
ton
high
efficiency
Note:
All dimensions are in inches/millimeters.
Figur
e
3.
3-5
ton
standard
efficiency
,
3
ton
high
efficiency
-
roof
curb
Note:
All dimensions are in inches/millimeters.
7
44
4
4
MM
M
M
44
4
4
MM
M
M
1038
1
0
3
8
MM
M
M
1053
1
0
5
3
MM
M
M
14
16
Table of Contents
Default Chapter
2
Important Environmental Concerns
2
Table of Contents
3
Model Number Description
5
Model Number Notes
6
Model Number Description - 17 Plus
7
Model Number Notes
8
General Information
9
Unit Inspection
9
Storage
9
Unit Nameplate
9
Compressor Nameplate
9
Microchannel Condenser Barcode ID
9
Unit Description
9
Economizer Control Actuator (Optional)
9
System Input Devices & Functions
10
Low Pressure Control
11
High Pressure Control
11
Power Exhaust Control (Optional)
11
Lead/Lag Control (Dual Circuit Only)
11
Evaporator Frost Control
12
Discharge Line Temp Switch (DLTS)
13
Smoke Detector Sensor (Optional)
13
Phase Monitor
13
Single Zone Variable Air Volume / Displacement Ventilation (Optional)
13
Unit Dimensions
14
Unit Clearances
14
Installation
21
Pre-Installation
21
Procedure
21
Foundation
23
Horizontal Units
23
Ductwork
23
Roofcurb
25
Downflow
25
Rigging
26
General Unit Requirements
26
Factory Installed Economizer
27
Temperature Limit Switch Usage for Electric
27
Heat Units
27
Horizontal Discharge Conversion
27
Ton Units)
27
Horizontal Discharge Conversion (6 through 10 Ton Units)
27
TCO-A Instructions
28
Return Air Smoke Detector
29
Main Electrical Power Requirements
29
Electric Heat Requirements
30
Low Voltage Wiring (AC & DC) Requirements
30
Condensate Drain Configuration
30
Filter Installation
31
Field Installed Power Wiring
31
Main Unit Power
31
Standard Wiring
31
Optional TBUE Wiring (through the Base Electrical Option)
31
Field Installed Control Wiring
32
Control Power Transformer
32
Controls Using 24 VAC
32
Controls Using DC Analog Input/Outputs (Standard Low Voltage Multi Conductor Wire)
33
Smoke Detector Customer Low Voltage wir
37
Ing
37
Space Temperature Averaging
37
Pre-Start
41
Voltage Imbalance
41
Electrical Phasing (Three Phase Motors)
41
Compressor Crankcase Heaters (Optional)
42
Reliatel™ Controls
42
Test Modes
43
Electromechanical Controls Test Procedure
43
Unit Start-Up
44
Verifying Proper Air Flow
44
Units with 5-Tap Direct Drive Indoor Fan
44
Units with Belt Drive Indoor Fan
44
Units with Direct Drive Indoor Fan - Electromechanical Control
45
Reliatel Units with Direct Drive Indoor Fan (7.5 - 10 Ton High Efficiency, 10 Ton Standard Efficiency)
45
Units with Constant CFM Direct Drive Indoor
46
Fan
46
Plus Units with the Constant CFM Direct Drive Indoor Fan
46
Vhr Relay Output
47
Variable Air Volume Applications
47
Vav)
47
Supply Duct Static Pressure Control
48
Supply Air Temperature Reset
48
Return Air Smoke Detector
49
Economizer Start-Up
49
Compressor Start-Up
50
Dehumidification Option
50
Final System Setup
51
Maintenance
52
Fan Belt Adjustment - Belt Drive Units
52
Monthly Maintenance
52
Filters
52
Return Air Smoke Detector Maintenance
53
Cooling Season
53
Heating Season
53
Coil Cleaning
53
Microchannel (MCHE) Coils
54
Round Tube Plate Fin (RTPF) Coils
54
Annual Maintenance
55
Final Process
55
Troubleshooting
56
Reliatel™ Control
56
System Status Checkout Procedure
56
Method 1
56
System Failure
56
Cooling Failure
57
Service Failure
57
Simultaneous Heat and Cool Failure
57
Resetting Cooling and Ignition Lockouts
57
Method 1
57
Method 2
57
Zone Temperature Sensor (ZTS) Service Indi
57
Cator
57
Clogged Filter Switch
58
Fan Failure Switch
58
Condensate Overflow Switch
58
Zone Temperature Sensor (ZTS) Test
58
Test 1 - Zone Temperature Thermistor (ZTEMP)
58
Test 2 - Cooling Set Point (CSP) and Heating Set Point (HSP)
58
Test 3 - System Mode and Fan Selection
58
Test 4 - LED Indicator Test
58
Cool & Service)
58
Method 1
58
Programmable & Digital Zone Sensor Test
59
Reliatel™ Refrigeration Module (RTRM) Default Chart
59
Unit Operation Without a Zone Sensor
59
Unit Economizer Control (ECA) Troubleshoot
59
Ing
59
Reliatel Control
59
Electro Mechanical Control
60
Unit Economizer Control (ECA) Test Proce
60
Dures
60
Troubleshooting Procedures for Direct Drive
60
Plenum Fan
60
Unit Wiring Diagrams Numbers
62
Limited Warranty
64
Electric Air Conditioner
64
TCY, TCX, TCC, TCD, TCH, TCM,TCP, TSC and THC (Parts Only) Models Less than 20 Tons for Residential Use
64
Electric Air Conditioner
65
TCY, TCX, TCC, TCD, TCH, TCK, TCM, TCP, TSC and THC (Parts Only) Models Less than 20 Tons for Commercial Use
65
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Trane TSC037E and is the answer not in the manual?
Ask a question
Trane TSC037E Specifications
General
Brand
Trane
Model
TSC037E
Category
Air Conditioner
Language
English
Related product manuals
Trane TSC060ED
44 pages
Trane TSC060-120
48 pages
Trane Precedent TSCSeries
64 pages
Trane Precedent TSJ072A
60 pages
Trane Voyager TSD/TSH 060
68 pages
Trane Voyager TS 150G Series
52 pages
Trane TTK060K4
68 pages
Trane Voyager TC*
108 pages
Trane TTZ048A100A1
6 pages
Trane TTA120D300AA
11 pages
Trane TTA090A series
32 pages
Trane TTA120B series
32 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
