Trane UD100R9V5K Series User Manual

Variable Speed, 2-Stage
Upflow / Horizontal and Downflow / Horizontal,
Gas-Fired Furnaces, “Fan Assisted
Combustion System”
A341789P03
Installer’s Guide
Downflow / Horizontal* Upflow / Horizontal*
For VENT SIZING INFORMATION see:
USA —
National Fuel Gas Code ......... ANSI Z223.1/NFPA 54 (latest version)
CANADA —
Natural Gas Installation Code ...... CAN/CGA-B149.1 (latest version)
Propane Installation Code ............. CAN/CGA-B149.2 (latest version)
USA/CANADA ALTERNATE —
Category I Venting Guide ......... Pub. No. 18-CH23D1 (latest version)
*Horizontal Conversion for these furnaces may be left or right side rotation.
ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES
IMPORTANT — This Document is customer property and is to remain with this unit.
Please return to service information pack upon completion of work.
*__First letter may be “A” or “T”
18- CD20D1- 18
AVAILABLE IN FRENCH CANADIAN (FC)
*UD060R9V3K
*UD080R9V3K
*UD080R9V4K
*UD100R9V3K
*UD100R9V5K
*UD120R9V5K
*UD140R9V5K
*DD060R9V3F
*DD080R9V3F
*DD100R9V5F
*DD120R9V5F

Trane UD100R9V5K Series Specifications

General

Model	UD100R9V5K Series
Type	Gas Furnace
Heating Capacity	100, 000 BTU
AFUE Rating	95%
Blower Motor	Variable Speed
Fuel Type	Natural Gas
Vent Type	Direct Vent
Stages	Two-Stage
Ignition Type	Hot Surface Ignition
Warranty	10-Year Limited Warranty on parts, Limited Lifetime Warranty on heat exchanger

Summary

SAFETY SECTION

FIRE OR EXPLOSION HAZARD

Warning regarding severe risks from improper servicing or handling.

GENERAL INSTALLATION INSTRUCTIONS

LOCATION AND CLEARANCES

AIR FOR COMBUSTION AND VENTILATION

DUCT CONNECTIONS

RETURN AIR DUCT CONNECTION

GENERAL VENTING INSTRUCTIONS

CARBON MONOXIDE POISONING HAZARD

Critical steps to prevent carbon monoxide poisoning from venting system issues.

VENTING INTO A MASONRY CHIMNEY

Guidance on safely venting the furnace into masonry chimneys.

VENT PIPING

EXTERNAL MASONRY CHIMNEY

ELECTRICAL CONNECTIONS

FIRE OR EXPLOSION HAZARD

GAS PIPING

COMBUSTION AND INPUT CHECK

HIGH ALTITUDE DERATE

START UP AND ADJUSTMENT

PRELIMINARY INSPECTIONS

Initial checks to perform before starting the furnace.

LIGHTING INSTRUCTIONS

SEQUENCE OF OPERATION

THERMOSTAT CALL FOR HEAT (2-STAGE)

THERMOSTAT CALL FOR HEAT (1-STAGE)

INDOOR BLOWER OPERATION (FAN ON)

ABNORMAL CONDITIONS

SAFETY WARNINGS AND PROCEDURES

PRECAUTIONARY MEASURES

FIRST AID MEASURES

WHAT TO DO IF YOU SMELL GAS

Emergency procedures to follow if gas is detected.

INTEGRATED FURNACE CONTROL ERROR FLASH CODES