TriangleTube PRESTIGE Series User Manual

3
CHAPTER 2
CHAPTER 2 - MAINTENANCE SCHEDULES
2.1. Service Technician
At least on an annual basis the following maintenance
should be performed by a qualied service technician:
General
• Attend to any reported problems.
• Inspect the interior of the boiler jacket area; clean
and vacuum if necessary.
• Clean the condensate drain assembly and ll with
fresh water.
• Check boiler uid pH on systems.
• Check for leaks, both inside and outside the unit:
water, gas, ue and condensate.
• Verify vent piping and air inlet piping are in good
condition, sealed tight and properly supported.
• Check boiler water pressure, piping and expansion
tank.
• Check control settings.
• Check ignition electrode (sand o any white oxide;
clean and reposition).
• Check ignition wiring and ground wiring.
• Check all control wiring and connections.
• Check burner ame pattern (stable and uniform).
• Check carbon monoxide detectors.
Additional items if combustion or performance is
poor:
• Clean heat exchanger and ue ways.
• Remove burner assembly and clean burner head
using compressed air only.
Service Technician maintenance procedures can be
found in Chapter 17 of the Prestige Installation and
Maintenance manual.
Once the maintenance items are completed, review
the service with the owner.
2.2. Owner Maintenance
Periodically:
• Check the area around the unit.
• Check and remove any blockage from the combus-
tion air inlet and ventilation openings.
• Check the temperature and pressure gauges.
Monthly:
• Check vent piping.
• Check combustion air inlet piping.
• Check the pressure relief valve.
• Check the condensate drain system.
Every 6 months:
• Check boiler piping and gas supply piping for cor-
rosion or potential signs of leakage.
• Operate the pressure relief valve.
• Check carbon monoxide detectors.
Follow the maintenance procedures given in
Chapter 3 on page 5 of this manual. Failure
to perform the service and maintenance or
follow the directions in this manual can result
in damage to the PRESTIGE or system com-
ponents, resulting in substantial property
damage, serious injury, or death.
WARNING

TriangleTube PRESTIGE Series Specifications

General

Model	PRESTIGE Series
Category	Boiler
Brand	Triangle Tube
Series	PRESTIGE
Heat Exchanger Material	Stainless Steel
Boiler Type	Condensing
Fuel Type	Natural Gas