TYM T194 - Page 109

F
TROUBLESHOOTING
F
7
5. ELECTRIC INSTRUMENTS SYSTEM
ISSUE CAUSE ACTION
E
L
E
C
T
R
I
C
S
Y
S
T
E
M
The battery won’t be charged
• Blown fusible link
• Defective wiring
• Defective alternator
• Loose or damaged fan belt
• Defective battery function
• Check the wiring and replace the fusible link
• Check for loose or missing terminal, short
circuit and poor ground and repair as
necessary
• Have it repaired by workshop
• Adjust the tension or replace the belt
• Check for loose or corroded terminal and
insufficient electrolyte and take any
necessary action
The headlamp does not produce
enough light
• Low charging level of battery
• Contact failure in wiring
• Charge
• Check, clean and re-tighten the ground and
terminal
The headlamp does not come on
• Blown bulb
• Blown fuse
• Contact failure
• Replace the bulb
• Check the wiring and replace the fuse
• Check and clean the ground and terminal
The horn does not operate
• Defective horn switch
• Defective wiring
• Damaged horn
• Replace
• Repair
• Repair or replace
The turn signal lamp does not blink
• Blown bulb
• Defective flasher unit
• Poor contact
• Replace the bulb
• Replace
• Check and clean the ground and terminal
The work lamp does not come on
• Blown bulb
• Contact failure
• Replace the bulb
• Check and clean the ground and terminal