TYM T433 - Roll-Bar Wiring Diagram

120 pages

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

T433/T503/T553 ROLL-BAR WIRING DIAGRAM

106

Table of Contents

Limited Warranty2
Warning Signs in this Manual5
Table of Contents6
Tractor Identification7
About this Manual8
Introduction & Description9
Description10
Owner Assistance12
Roll over Protective Structures (ROPS)13
ROPS (Roll over Protection Structures)13
- Damage of the ROPS14
- For Sliding Seat15
Safety Instructions, Do's & Don16
- Use of ROPS and Seat Belt17
- Precaution to Avoid Tipping17
- Park Tractor Safely17
- Fuel Handling18
- Danger of Rotating Shafts18
- Safety Lights and Devices18
- Safe Maintenance18
- Safe Service19
- Prevent Acid Burns19
- Avoid High-Pressure Fluids19
- Prevent Battery Explosions19
- Work in Ventilated Area20
- Tractor Runaway20
- Safety Starter Switch20
- Safe Operation21
- Safety Tips During Maintenance22
- Mounting and Demounting Implements23
- Precautions to Help Prevent Accidents24
- Do's and Don't's27
- Decals on the Dash Cover29
Safety Signs29
Decals on the Cabin30
Universal Symbols32
- Controls Description34
- Instrument and Switches34
- Warning Lights36
- Tractor Controls39
- Throttle Lever (Hand Throttle)39
- Foot Operated Accelerator40
- Clutch Cut-Off Alarm40
- Foot Operator Accelerator40
- Sub Gear Lever (Linear Shift Lever)41
- Shuttle Shift Lever41
- Main Gear Lever41
- To Avoid Personal Injury42
- Diff-Lock Pedal42
- Front Wheel Drive Lever43
- Driver's Seat Adjustment43
- Tilt Lever43
- Position Control44
- PTO Gear Selection Lever44
- Operating the Hydraulics44
- Lowering Speed Control Knob for the 3 Point Hitch45
- Draft Control Lever45
- Exterior Hydraulic Lever46
- Remote Hydraulic Control Valve Coupler Connecting and Disconnecting46
- Joystick Lever46
- Safety Implement for Joystick Lever47
- Operating the 3 Point Linkage (TPL)48
- Adjustment of the Lower Link49
- Telescopic Stabilizers Adjustment49
- Adjustment of the Top Link49
- Adjustment of the Lift Link on the Lower Link]50
- Mounting Implement50
- Driving the Tractor51
- Starting the Engine51
- Stopping the Engine51
- Warming up52
- Storing Engine in Operable Condition for 3 Months or more52
- Normal Braking and Parking53
- Tight Turns in the Field53
- Uphill Starts on a Steep Slope54
- Operation of the Diff Lock54
- Check During Riding54
- Fuel Gauge55
- Engine Cooling Water55
- Track Adjustment56
- Lubrication and Maintenance59
- Engine Oil Check60
- Transmission Oil Check60
- Engine Coolant Check60
- Pre-Start Checks60
- Fuel61
- Tyre Pressure61
- Brake Check62
- Clutch Check62
- Installing Loader62
- Detaching Loader62
- Maintenance and Adjustment Schedule63
- Periodical Check and Service Table63
- Filling Diagram and Capacity Table66
- Recommended Transmission Oil67
- Opening Method of Hood67
- Opening the Side Cover67
- Bleeding the Fuel System68
- Changing the Oils in the Tractor68
- Changing Engine Oil68
- Changing the Transmission Oil69
- Changing Oil in the Front Axle70
- Cleaning and Changing Filters70
- Engine Oil Filter70
- Fuel Filter71
- Changing the Coolant72
- Hydraulic Oil Filter and Engine Oil Filter Cartridge72
- Anti Freeze73
- Cleaning the Radiator73
- Greasing the Tractor74
- Gap Adjustment75
- Adjusting the Clutch75
- Adjusting the Brakes75
- Adjusting the Throttle Lever76
- Adjusting Toe-In76
- Fan Belt Adjustment77
- Battery Maintenance77
- Battery Charging77
- Alternator Inspection78
- Alternator and Fan Belts Inspect/Adjust/Replace78
- Air Conditioner Compressor Belt Adjustment79
- Servicing the Air Cleaner79
- Checking Hoses and Lines79
- Checking the Wiring Harness and Fuses80
- Replacing Fuses80
- Service Prior to Daily and Short Terms Storage80
- Long-Term Storage81
- Re-Use after Long Term Storage81
Cabin82
- Instrument and Related Parts83
- Working Lamps (Front and Rear)84
- Rearview Mirrors84
- Cab Ceiling84
- How to Control Cabin84
- Windscreen Washer Tank85
- Re-Circulation Inlets Fully Closed85
- Ventilation85
- Working Lamp Switch/Wiper Control Switch85
- Blower Control Switch86
- Temperature Control86
- Air Con. Switch86
- Circulation Diffuser86
- Heating System87
- Air Conditioning System89
- Compressor Belt Adjustment89
- Radio, CD Player90
- Cigarette Lighter90
- Cab Air Intake Filter90
- Roof Hatch90
- Checking the Air Conditioning System91
- Checking the Air Conditioning System Charge91
- Check the Refrigerant with Receive Drier Sight Glass91
- Diagnosing Malfunctions92
- Tracing Faults92
- To Check the Air Conditioning System with the Needle of High Low Gauge93
Specifications94
Fuel Saving Tips101
Fault Tracing103
- Wiring Diagram107
- Electric System Diagram109
- Roll-Bar Wiring Diagram110
- Cabin Wiring Diagram111
- Drawing for Fixing Position of the Fuse114
- Wiring Diagram of the Electric Instrument114
- Power Train Diagram115
Tractor History Card116
Service Record117
Daily Operating Log118
Part Replacement Record119

Related product manuals

Preview: TYM T431

Preview: TYM T474

Preview: TYM T454

Preview: TYM T400

Preview: TYM T454HST

Preview: TYM T264

Preview: TYM T723

Preview: TYM T293HST