Upright SL30SL - Page 28

Service and Repair
3-2
Preventative Maintenance Table Key
Interval
Daily=each shift or every day
50h/30d=every 50 hours or 30 days
250h/6m=every 250 hours or 6 months
1000h/2y=every 1000 hours or 2 years
Y=Yes/Acceptable N=No/Not Acceptable
R=Repaired/Acceptable
Preventative Maintenance Report
Date:___________________________________
Owner: _________________________________
Model No: _______________________________
Serial No: _______________________________
Serviced By: _____________________________
Service Interval: __________________________
Table 3-1: Preventative Maintenance Check list
COMPONENT INSPECTION OR SERVICES INTERVAL Y N R
Battery
System
Check electrolyte level Daily
Check specific gravity 6m
Clean exterior 6m
Check battery cable condition Daily
Clean terminals 6m
Engine Oil
Check level and condition Daily
Check for leaks Daily
Change oil filter 30d
Engine Fuel
System
Check fuel level Daily
Check for leaks Daily
Replace fuel filter 6m
Check air cleaner Daily
Engine
Coolant
Check coolant level (with engine cold) Daily
Replace coolant 3m
Hydraulic Oil
Check oil level Daily
Change filter 6m
Drain and replace oil 2y
Hydraulic
System
Check for leaks Daily
Check hose connections 30d
Check hoses for exterior wear 30d
Emergency
Hydraulic
System
Operate the emergency lowering valve and
check for serviceability
Daily
Controller Check switch operation Daily
Control Cable
Check the exterior of the cable for pinching,
binding or wear
Daily
Platform Deck
and Rails
Check fasteners for proper torque Daily
Check welds for cracks Daily
Check condition of deck Daily
Tires
Check for damage Daily
Check lug nuts (torque to 90 ft. lbs.) 30d
Hydraulic
Pump
Wipe clean 30d
Check for leaks at mating surfaces 30d
Check for hose fitting leaks Daily
Check mounting bolts for proper torque 30d
Drive Motors Check for operation and leaks Daily