5252
Front WheelFront Wheel
（（
11
））
Place lift truck on Place lift truck on level concrete.level concrete.
（（22））Start engine and raise carriage about 100mmStart engine and raise carriage about 100mm
height.height.
（（33））Place chocks behind rear wheels to preventPlace chocks behind rear wheels to prevent
movement of forklift.movement of forklift.
（（
44
））
Loosen wheel nuts 1Loosen wheel nuts 1--2 turns each by turning2 turns each by turning
them counterthem counter--clockwise.clockwise.
（（55））Tilt mast fully backward, and place a woodenTilt mast fully backward, and place a wooden
block under each side of outer mast.block under each side of outer mast.
（（
66
））
Tilt mast forward until front tires are raisedTilt mast forward until front tires are raised
from surface.from surface.
!! CCaauuttiioonn
Do not allow loose nuts before the frontDo not allow loose nuts before the front
wheels leave the ground.wheels leave the ground.
（（
77
））
Support forklift truck by putting additionalSupport forklift truck by putting additional
wooden blocks under each side of the frontwooden blocks under each side of the front--end frameend frame
as shown below. Stop the engine.as shown below. Stop the engine.
（（
88
））
Take out the wheel nuts and replace the frontTake out the wheel nuts and replace the front
wheel tire.wheel tire.
!! WWaarrnniinngg
a. When removing tire from wheel rim, do nota. When removing tire from wheel rim, do not
remove rim set bolts and nuts beforeremove rim set bolts and nuts before
releasing air. (Pneumatic)releasing air. (Pneumatic)
b. Make sure that wooden blocks used tob. Make sure that wooden blocks used to
support lift truck are solid, onesupport lift truck are solid, one--piece units.piece units.
c. Never get under forklift while it is supportedc. Never get under forklift while it is supported
only by wooden blocks.only by wooden blocks.
https://www.forkliftpdfmanuals.com/
To Next Page
Loading...
