Volvo Penta 5.7Gi-E - Page 69

VPA 7743722 English 10-2004 65
Maintenance
Function Adjust Check Lubricate Fill Replace Tighten
Once per season
Bellows and clamps, drive unit
1
1. Check at 50-hour intervals; replace as necessary or once every two years, whichever comes first.
••
Exhaust manifold and risers
•
Distributor cap and rotor
•
Fuel filter, carburetor
•
Fuel filter, engine
•
Fuel system (leakage)
•
Impeller, water pump
1
•
Oil, engine crankcase
2
2. Mineral oil - once per season or every 100 operating hours, whichever comes first. Synthetic oil - once per season or 200 operating
hours, whichever comes first.
•
Oil drive unit
•
Oil filter (engine)
2
•
Propeller and shaft
••
Remote control shift cable (damage)
•
Spark plugs (3.0 liter models)
3
3. For all other engines: Once every 3 years or 500 operating hours, whichever comes first.
•
Spark plug wires/boots (deterioration)
4
4. Replace as needed: Once every 3 years or 500 operating hours, whichever comes first.
•
Steering system cable (operation)
5
5. Lubricate once per season or every 50 operating hours, whichever comes first.
•
Throttle cable (damage and operation)
••
Belt: serpentine (3.0GL; all fuel-injected models)
•
Carburetor adjustment (as needed)
•
Engine alignment and mounting screws
•
Exhaust manifold and risers (corrosion/blockage)
•
Gimbal bearing
•
PCV valve
•
Shift system (operation)
••
Universal joints (SX and DPS)
•
Universal joint bellows
•
Drive shaft splines
•
7743722 - Downloaded from www.volvopenta.com 13/05/2008 20:17:06