Why does my Westinghouse iGen4000DFc Portable Generator engine start, then shuts down?
If your Westinghouse Portable Generator starts and then shuts down, it could be due to several reasons: * The fuel level might be low or depleted, so refuel it. * The engine oil level might be incorrect, so check it. * The air filter might be dirty, so clean it. * The gasoline might be contaminated, so drain the fuel tank and refuel with fresh gasoline.
What to do if Westinghouse Portable Generator engine lacks power?
If your Westinghouse Portable Generator engine lacks power, consider these potential causes: * The air filter might be restricted, so clean or replace it. * The gasoline might be stale, or the generator was stored without treating or draining the gasoline, so drain the fuel tank and refuel with fresh gasoline.
What to do if Westinghouse iGen4000DFc Portable Generator engine runs rough or bogs when load applied?
If your Westinghouse Portable Generator runs rough or bogs down when a load is applied, try these solutions: * Clean the air filter, as it might be dirty. * Unplug some devices to reduce the load, as the generator might be overloaded. * Replace or repair any faulty power tool or appliance, then stop and restart the engine.
Why Westinghouse Portable Generator has no power at AC receptacles?
If there's no power at the AC receptacles of your Westinghouse Portable Generator, check the following: * If the OUTPUT READY LED is OFF and the OVERLOAD LED is ON, check the AC load and try stopping and restarting the engine. * See if the AC circuit breaker(s) have tripped; if so, check the AC loads and reset them. * Consider whether you have a faulty power tool or appliance connected. Replace or repair the item, then stop and restart the engine.
Why is there frost on the propane tank or regulator of my Westinghouse Portable Generator?
Frost on the propane tank or regulator of your Westinghouse Portable Generator can occur if the tank's temperature drops below the dew point, especially in humid conditions. If all propane fuel handling equipment is functioning normally, no correction is needed. If you suspect your propane fuel tank is not equipped with an Overfilling Prevention Device (OPD), discontinue operation immediately and replace the propane fuel tank with a propane tank equipped with a an OPD. If you suspect your propane fuel tank has been overfilled, discontinue operation immediately and return the propane fuel tank to the place of purchase or refilling.
Why do I smell propane fuel from my Westinghouse iGen4000DFc Portable Generator?
A propane fuel smell from your Westinghouse Portable Generator could be due to a few reasons: * The fuel regulator, hose, or fittings might not be securely sealed. Use a soap solution to check each connection and tighten as needed. * The propane fuel regulator vent might be active, which is normal if the venting is brief. If you suspect it's abnormal, discontinue use immediately and have the regulator inspected by a qualified technician. * It could also be residual fuel dispersing from the carburetor after operation, which is normal and requires no correction.
How to fix poor performance or engine stalling on Propane in Westinghouse iGen4000DFc?
To address poor performance or engine stalling on propane in your Westinghouse Portable Generator: * Inspect the propane fuel line for kinks or obstructions and remove them. * Ensure the fuel selector valve is properly positioned, fully in line with the desired fuel. * Purge any gasoline from the carburetor before switching to propane by closing the propane fuel tank valve, moving the fuel selector switch to gas, starting the engine, and allowing it to run until the gasoline is consumed. Then, begin the propane start-up procedure.
What to do if Westinghouse iGen4000DFc Portable Generator engine will not start?
If your Westinghouse Portable Generator's engine won't start, there are several things to check: * Make sure it has fuel. * Ensure the gasoline isn't stale; drain the tank and refuel with fresh gasoline. * Check and clean the air filter if it's dirty. * If the LOW OIL LED is illuminated, turn the battery switch OFF and add engine oil. * If the spark plug is wet with fuel, wait five minutes, turn the fuel selector switch to the PROPANE position, and pull the recoil handle rapidly several times. If it still doesn't start, remove and dry the spark plug. * Inspect the spark plug for faults or improper gapping; gap or replace it and reinstall. * Verify that the CO sensor hasn't been removed or modified and return it to its original configuration. * Relocate generator if CO sens...
Register your product for trouble-free warranty coverage.
Details on AC voltage, power, fuel type, oil capacity, etc.
Explanation of hazard terms and safety alert symbols.
Key precautions to prevent injury, fire, and carbon monoxide poisoning.
Guidelines for safe handling of gasoline, propane, and their vapors.
Details on CO sensor, hazards, and indicator lights.
Understanding and managing the generator's power output and load limits.
Guidelines for selecting and using extension cords safely.
Description of AC receptacles, CO sensor lights, and LEDs.
Information on connecting generators in parallel and USB charging ports.
Instructions for unpacking, inspecting, and checking included items.
Essential placement and operating guidelines for safe use.
Procedures for checking oil, adding gasoline, and propane requirements.
Guides for starting (gasoline/propane) and stopping the generator.
Using Eco mode and resetting generator after overload.
How to connect two generators for increased power output.
Safety guidelines for transporting the generator.
Procedures for cleaning the generator, air filter, and spark arrestor.
Instructions for changing engine oil and spark plug.
Procedures for draining fuel tank and float bowl.
Checking valve clearance and replacing the fuel filter.
Guidelines for storing the generator and the maintenance schedule.
Table of common problems, causes, and corrections.
General| Starting Watts | 4000 |
|---|---|
| Running Watts | 3500 |
| Engine Type | 4-Stroke OHV |
| Fuel Tank Capacity | 3.4 gallons |
| Run Time (Gasoline) | 18 hours at 25% load |
| Noise Level | 52 dBA |
| Inverter | Yes |
| AC Output | 120V |
| Voltage | 120V |
| Frequency | 60 Hz |
| Wheels | No |
| Parallel Capable | Yes |
| CARB Compliant | Yes |
| Fuel Type | Gasoline / Propane |
| Outlets | 1 x 12V DC |
| Starting System | Recoil Start |
| Warranty | 3 years |
| Engine Displacement | 224 cc |
To Next Page
