Westinghouse iGen4500DF User Manual (English)

Other manuals for Westinghouse iGen4500DF

Questions and Answers:

J
Jason JohnsJul 27, 2025
Why won't my Westinghouse iGen4500DF Portable Generator start?
- H
  Hannah HancockJul 27, 2025
  Your Westinghouse Portable Generator might not start due to several reasons: the battery switch may be in the OFF position (turn it to ON); it might be out of fuel (refuel it); the fuel could be bad (drain and refuel with fresh gasoline); the air filter could be dirty (clean it); the engine oil level might be low (add engine oil); the spark plug could be wet with fuel (wait five minutes, turn the battery switch to the OFF position, pull the recoil handle rapidly several times, and if it doesn't start, remove and dry the spark plug); the spark plug might be faulty (gap or replace it); the battery could be drained (use the recoil handle to start the generator); or the choke might be partially open or closed (manually set the choke).
E
Emily NguyenAug 5, 2025
What to do if my Westinghouse iGen4500DF engine will not start?
- A
  Aaron WhitakerAug 6, 2025
  If your Westinghouse Portable Generator's engine won't start, try these steps: Ensure the battery switch is in the ON position. Check the fuel level and refuel if necessary, using fresh gasoline. Inspect and clean the air filter. Verify the engine oil level is adequate. If the spark plug is wet, wait a few minutes before attempting to start again. If these steps don't work, the spark plug might need gapping or replacement. If the battery is drained, use the recoil handle. Also, manually set the choke.
M
Melanie FullerAug 15, 2025
How to fix a Westinghouse iGen4500DF that will not start?
- T
  Timothy BarnesAug 16, 2025
  To fix a Westinghouse Portable Generator that won't start: First, make sure the battery switch is in the ON position. Then, check if the generator is out of fuel and refuel if needed, ensuring you use fresh gasoline. A dirty air filter can also prevent starting, so clean it. Low engine oil can be a culprit, so add oil if the level is low. If the engine is flooded (spark plug wet), wait a few minutes before trying again. Check the spark plug for faults and gap or replace if necessary. If the battery is drained, use the recoil handle to start. Finally, manually adjust the choke.

Westinghouse iGen4500DF Specifications

General

Starting Wattage	4500 Watts
Running Wattage	3700 Watts
Fuel Type	Gasoline/Propane
Engine Type	4-Stroke OHV
Engine Displacement	224 cc
Runtime at 50% Load (Gasoline)	18 Hours
Noise Level	52 dBA
DC Output	12V 8.3A
Tank Capacity	3.4 Gallons
Starting Method	Electric Start
Wheel Kit	Included

Summary

SPECIFICATIONS

NOTICE

Important operational notes and ambient temperature limits for the generator.

PRODUCT REGISTRATION

Instructions and links for registering the generator for warranty coverage.

SAFETY DEFINITIONS

SAFETY SYMBOLS

Explanation of hazard symbols and their meanings used in the manual and on the generator.

SAFETY INSTRUCTIONS

CORRECT USAGE

Guidelines for safe generator placement and operation to prevent carbon monoxide poisoning.

INCORRECT USAGE

Prohibited locations for generator operation to avoid safety hazards.

GENERAL SAFETY PRECAUTIONS

FUEL SAFETY

Precautions for safe handling and storage of gasoline and propane fuel.

LIQUID PETROLEUM GAS (LPG/PROPANE)

Starting LPG/Propane Operations

Procedures for connecting and starting the generator with LPG/propane.

Transporting and Storing LPG/Propane

Safety guidelines for handling propane tanks during transport and storage.

SAFETY LABELS AND DECALS

GENERATOR COMPONENTS

DIGITAL DATA CENTER

Description of the generator's digital display for fuel, power, voltage, and runtime.

CONTROL PANEL COMPONENTS

CARTON CONTENTS

INITIAL OIL FILL

Critical instructions for adding engine oil before first use to prevent severe engine damage.

FUEL

USING FUEL STABILIZER

Guidance on using fuel stabilizer to maintain gasoline quality during storage.

FILLING THE FUEL TANK

Step-by-step instructions for safely filling the generator's fuel tank.

CONNECT A LPG/PROPANE TANK

Procedure for correctly connecting a propane tank to the generator.

CONNECT THE BATTERY

GENERATOR LOCATION

GROUNDING

Information and safety precautions regarding generator grounding procedures.

HIGH ALTITUDE OPERATION

Necessary adjustments for optimal generator performance at altitudes above 5,000 feet.

REMOTE START

REPROGRAMMING THE REMOTE START

Instructions for re-pairing or reprogramming the remote start key fob to the generator.

FUEL SELECTOR SWITCH

BREAK-IN PERIOD

BEFORE STARTING THE GENERATOR

STARTING THE ENGINE

STARTING THE ENGINE: GASOLINE

Procedure for starting the generator using gasoline fuel.

STARTING THE ENGINE: LPG

Procedure for starting the generator using LPG/propane fuel.

SWITCHING FUEL SOURCES

STOPPING THE ENGINE

FREQUENCY OF USE

ECO MODE

AC CIRCUIT BREAKERS

OVERLOAD RESET

GENERATOR CAPACITY

POWER MANAGEMENT

Guidelines for managing electrical loads to prolong generator life and performance.

EXTENSION CORDS

EXTENSION CORD SIZING

Recommended extension cord gauges for different amperage loads and distances.

PARALLEL OPERATION

Instructions for connecting two compatible generators for increased power output.

TRANSPORTING

MAINTENANCE SCHEDULE

ENGINE SERVICE COVER

Procedure for removing the engine service cover to access internal components.

AIR FILTER MAINTENANCE

Steps for cleaning and maintaining the generator's air filter.

ENGINE OIL LEVEL CHECK

ENGINE OIL CHANGE

SPARK PLUG MAINTENANCE

Procedures for inspecting, cleaning, and replacing the spark plug for optimal performance.

SPARK ARRESTOR SERVICE

BATTERY MAINTENANCE

Recommendations for maintaining battery charge and preventing discharge during storage.

BATTERY REPLACEMENT

Detailed instructions for safely replacing the generator's battery.

STORAGE

DRAINING THE FLOAT BOWL

Procedure for draining the carburetor float bowl to prevent fuel system issues during storage.

DRAINING THE FUEL TANK

Steps for draining the fuel tank for long-term storage to prevent fuel degradation.

VALVE CLEARANCE

MANUALLY SET THE CHOKE

Instructions for manually operating the choke when the battery is dead or disconnected.

TROUBLESHOOTING

EXPLODED VIEW A

EXPLODED VIEW B

EXPLODED VIEW A & B PART NUMBERS

Comprehensive list of part numbers and descriptions for Exploded Views A and B.

EXPLODED VIEW A & B PART NUMBERS (CONTINUED)

EXPLODED VIEW C

EXPLODED VIEW C PART NUMBERS

EXPLODED VIEW C PART NUMBERS (CONTINUED)

SCHEMATICS

Related product manuals

Westinghouse iGen4500

52 pages

Westinghouse iGen4500c

32 pages

Westinghouse iGen4500s

56 pages

Westinghouse iGen4000c

80 pages

Westinghouse iGen4000DFc

92 pages

Westinghouse iGen2200

56 pages

Westinghouse iGen2500

56 pages

Westinghouse iGen2800

76 pages

Westinghouse iGen5000

84 pages

Westinghouse iGenTent

22 pages

Westinghouse iGen5000DFc

92 pages

Westinghouse iGen11000DFc

32 pages

Westinghouse iGen4500DF User Manual

Table of Contents

Other manuals for Westinghouse iGen4500DF

Questions and Answers:

Westinghouse iGen4500DF Specifications

Summary

SPECIFICATIONS

NOTICE

PRODUCT REGISTRATION

SAFETY DEFINITIONS

SAFETY SYMBOLS

SAFETY INSTRUCTIONS

CORRECT USAGE

INCORRECT USAGE

GENERAL SAFETY PRECAUTIONS

FUEL SAFETY

LIQUID PETROLEUM GAS (LPG/PROPANE)

Starting LPG/Propane Operations

Transporting and Storing LPG/Propane

SAFETY LABELS AND DECALS

GENERATOR COMPONENTS

DIGITAL DATA CENTER

CONTROL PANEL COMPONENTS

CARTON CONTENTS

INITIAL OIL FILL

FUEL

USING FUEL STABILIZER

FILLING THE FUEL TANK

CONNECT A LPG/PROPANE TANK

CONNECT THE BATTERY

GENERATOR LOCATION

GROUNDING

HIGH ALTITUDE OPERATION

REMOTE START

REPROGRAMMING THE REMOTE START

FUEL SELECTOR SWITCH

BREAK-IN PERIOD

BEFORE STARTING THE GENERATOR

STARTING THE ENGINE

STARTING THE ENGINE: GASOLINE

STARTING THE ENGINE: LPG

SWITCHING FUEL SOURCES

STOPPING THE ENGINE

FREQUENCY OF USE

ECO MODE

AC CIRCUIT BREAKERS

OVERLOAD RESET

GENERATOR CAPACITY

POWER MANAGEMENT

EXTENSION CORDS

EXTENSION CORD SIZING

PARALLEL OPERATION

TRANSPORTING

MAINTENANCE SCHEDULE

ENGINE SERVICE COVER

AIR FILTER MAINTENANCE

ENGINE OIL LEVEL CHECK

ENGINE OIL CHANGE

SPARK PLUG MAINTENANCE

SPARK ARRESTOR SERVICE

BATTERY MAINTENANCE

BATTERY REPLACEMENT

STORAGE

DRAINING THE FLOAT BOWL

DRAINING THE FUEL TANK

VALVE CLEARANCE

MANUALLY SET THE CHOKE

TROUBLESHOOTING

EXPLODED VIEW A

EXPLODED VIEW B

EXPLODED VIEW A & B PART NUMBERS

EXPLODED VIEW A & B PART NUMBERS (CONTINUED)

EXPLODED VIEW C

EXPLODED VIEW C PART NUMBERS

EXPLODED VIEW C PART NUMBERS (CONTINUED)

SCHEMATICS

Related product manuals