Westinghouse WGen6000 User Manual (English)

Questions and Answers:

K
Katherine YoungAug 4, 2025
Why is my Westinghouse WGen6000 Portable Generator running but not producing electricity?
- D
  Dawn KingAug 4, 2025
  If your Westinghouse Portable Generator's engine runs but provides no electrical output, several factors could be at play. First, check if the circuit breakers have tripped and reset them, watching for any overload. Ensure the power cord's plug is fully engaged in the generator's outlet, rotating clockwise if using the 240V outlet. Replace the power cord if it's faulty. Test with a known working appliance to rule out issues with the connected device. Also, verify that the GFCI outlet is not tripped by pressing the reset button on it. If none of these steps work, the generator may have an internal fault, and it is recommended to take it to an authorized service dealer.
R
Randy LopezAug 12, 2025
What to do if Westinghouse Portable Generator suddenly stops?
- S
  Scott OliverAug 12, 2025
  If your Westinghouse Portable Generator suddenly stops running, there are a few things you should check. First, make sure the generator has enough fuel. If the fuel level is sufficient, check the oil level, as the low oil shut down switch may have stopped the engine. Finally, too much load can cause the generator to stop. Try restarting the generator and reducing the load. If the issue persists after checking these, the generator may have a fault that requires attention from an authorized service dealer.
J
Jaime HughesAug 19, 2025
Why does my Westinghouse Portable Generator run erratically?
- R
  Rebecca HernandezAug 19, 2025
  If your Westinghouse Portable Generator engine runs erratically and doesn't maintain a steady RPM, there are a few potential causes. First, check if the choke was left in the ON position and move it to the OFF position. A dirty air filter can also cause this issue, so clean the air filter. Also, note that changes in engine speed may occur as applied loads cycle. This is normal. If these steps don't resolve the issue, the generator may have a fault that requires attention from an authorized service dealer.

Westinghouse WGen6000 Specifications

General

Brand	Westinghouse
Model	WGen6000
Category	Portable Generator
Language	English

Summary

TECHNICAL SPECIFICATIONS

PRODUCT REGISTRATION

WHERE IS MY SERIAL NUMBER?

Locating the unique serial number for generator registration.

SAFETY

SAFETY DEFINITIONS

Explains the meaning of DANGER, WARNING, CAUTION, and NOTICE terms.

SAFETY SYMBOL DEFINITIONS

Defines the meaning of various safety alert symbols used in the manual.

GENERAL SAFETY RULES

Provides fundamental safety guidelines for operating the generator.

SAFETY LABELS AND DECALS

Details the location and meaning of safety labels affixed to the generator.

UNPACKING

WHAT COMES IN THE BOX

Lists all components and accessories included in the generator packaging.

WHEEL KIT ACCESSORIES BOX

Instructs on checking the contents of the wheel kit accessories box.

ASSEMBLY

INSTALLING WHEELS AND FEET

Step-by-step guide for attaching wheels and mounting feet to the generator.

CONNECTING THE BATTERY

Provides instructions on correctly connecting the generator's battery.

FEATURES

Generator Components Overview

Identifies and describes the main external parts and features of the generator.

Control Panel Features

Details the functions of the control panel components and indicators.

OPERATION

BEFORE STARTING THE GENERATOR

Outlines essential steps and checks before operating the generator.

POWER CORD

Guidance on selecting and using appropriate extension cords with the generator.

CONNECTING THE GENERATOR TO A BUILDING ELECTRICAL SYSTEM

Instructions for safely connecting the generator to a building’s electrical system.

ADDING GASOLINE TO THE FUEL TANK

Safe procedures for adding gasoline to the generator's fuel tank.

POWER OUTPUT AND DEMAND

Explains how to match appliance power needs to generator output.

STARTING THE GENERATOR

Step-by-step guide on how to start the generator.

STOPPING THE GENERATOR

Procedures for properly stopping the generator during normal and emergency situations.

MAINTENANCE

MAINTENANCE SCHEDULE

Outlines periodic maintenance tasks and recommended intervals.

CLEANING THE SPARK ARRESTOR

Instructions for cleaning the spark arrestor component.

DRAINING CARBURETOR FLOAT BOWL

Procedure for draining the carburetor float bowl.

ENGINE OIL MAINTENANCE

Covers oil specifications, checking, and adding engine oil.

CHANGING ENGINE OIL

Detailed steps for performing an engine oil change.

AIR FILTER MAINTENANCE

Guide on cleaning and maintaining the generator's air filter.

SPARK PLUG MAINTENANCE

Instructions for checking, cleaning, and replacing the spark plug.

CHECKING AND ADJUSTING VALVE LASH

Procedure for checking and adjusting engine valve clearance.

TESTING GFCI OUTLETS

Steps for testing the Ground Fault Circuit Interrupter (GFCI) outlets.

BATTERY SERVICE

Guidance on battery charging and maintenance.

BATTERY REPLACEMENT

Steps for safely replacing the generator's battery.

CLEANING THE GENERATOR

Instructions for cleaning the exterior of the generator unit.

STORING GENERATOR

Procedures for preparing and storing the generator for extended periods.

TROUBLESHOOTING

Engine is running, but no electrical output

Addresses issues where the generator runs but produces no power.

Engine will not start or remain running while trying to start

Troubleshoots problems preventing the engine from starting or staying on.

Generator suddenly stops running

Solutions for when the generator stops unexpectedly during operation.

Engine runs erratic; does not hold a steady RPM

Diagnoses and resolves engine performance issues like unstable RPMs.

WGEN6000 EXPLODED VIEW

Exploded View Parts List

A comprehensive list of all parts shown in the exploded view diagram.

WGEN6000 ENGINE VIEW

Engine View Parts List

A comprehensive list of all parts shown in the engine view diagram.

WGEN6000 SCHEMATIC

WGen6000 Generator Specifications

Related product manuals

Westinghouse WGen7500

44 pages

Westinghouse WGen9500

29 pages

Westinghouse WGen3600

36 pages

Westinghouse WGen5300s

34 pages

Westinghouse WGen9500DF

35 pages

Westinghouse WGen20000c

93 pages

Westinghouse WGen5300DF

38 pages

Westinghouse WGen3600DF