Yamaha DR2E17 - Maintenance - Periodic Charts; Periodic Maintenance Schedule; Maintenance Safety Warning; High-Pressure Washer Usage Notice

1
2
3
4
5
6
7
8
9
10
11
7-1
J0C
MAINTENANCE
PERIODIC MAINTENANCE CHARTS
Regular maintenance is required for the best performance and safe operation of
your golf car.
Be sure to turn off the main switch and apply the parking brake when you per-
form maintenance, unless otherwise specified. If the owner is not familiar with
servicing the machine, death or serious personal injury can result. When in
doubt the work should be done by a Yamaha dealer or other qualified mechanic.
Yamaha Golf-Car Company does not approve the use of high-pressure washers
to clean the products they manufacture. Doing so may damage the finish on the
body or result in doing other damage not covered by warranty.
NOTICE
Daily
Pre-
Opera-
tion
20 hours
100 miles
160 kms
(Every
Month)
125 hrs
600 mls
1000 kms
(Every 6
months)
250 hrs
1200 mls
2000 kms
(Every
Year)
500 hrs
2500 mls
4000 kms
(Every 2
years)
1000 hrs
5000 mls
8000 kms
(Every 4
years)
PageRemarks
40 rounds 250 rounds 500 rounds 1000 rounds 2000 rounds
Charge
PRE-OP
EVERY
MONTH
EVERY 6
MONTHS
3-3/
7-5
5-2/
7-3
5-4/
7-20
*
*
*
*
*
5-3
5-3
5-2
5-4
7-3/7-4
*
Items without a page number reference should be serviced by a Yamaha dealer or other qualified mechanic. This manual does
not contain these procedures. They are contained in the Service Manual.
CS - CHECK CA - CHECK AND ADJUST R - REPLACE S - SERVICE CL - CLEAN AND LUBRICATE L - LUBRICATE
Clean battery tops, check for
tightness of hold-down screws and
terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure, tread depth,
tire surface for damage
Check body and chassis for
damage
Check tightness of all bolts, nuts,
screws and rivets
Check for loose or broken
connections
Check all wire insulation for cracks
and/or worn spots
Check shock absorbers for oil leaks
and damaged springs
Clean/Lube pedal control area
Check reverse alarm operation
Check electrolyte level
S
S
CS
CS
CS
S
S
CA
CA
CL
CS
S
S
CA
CA
CS
S
S
CA
CA
CS
S
S
CA
CA
CS
S
S
CA
CA
CS
CS CS CS CS CS CS
CS CS CS CS CS CS
CS CS CS CS CS CS
CS CS CS CS CS
CS CS CS CS CS
CS CS CS CS
CS CS CS CS
J0C-F8199-60.qxp_LIT_19626_16_05.qxd 6/27/16 2:50 PM Page 24