Yanmar EB3100 - Operate a New Tractor; Always run the tractor at less than full speed during the first 50 hours of operation; Change the lubricating oil for the new tractor

164 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

Table of Contents

COVER1
INTRODUCTION3
- Welcome to the World of Yanmar Tractor3
PICTOGRAPHS4
1. SAFETY PRECAUTIONS11
- About The Operator’s Manual11
- Safety Alert Symbol12
- Precautions Before Operating The Tractor13
- Safe Practices for Operating the Tractor14
- Operate the Tractor on Slopes16
- Travel on a Road17
- Safe Practices for Parking the Tractor17
- Operate the Power Take Off (PTO)18
- Use the 3-Point Hitch18
- Roll-Over Protective Structure (ROPS) Precautions18
- Safe Practices for Servicing the Tractor19
- Replace the rubber product/s such as Hydraulic Hose, Fuel Hoses, Power Steering Hoses, Radiator Hoses and Air Intake Hoses for Every 2 Years20
- This tractor is not designed for forest industry, quarry or mining use20
- Safe Operation of Implements and Attachments21
- Understand the Tractor Safety Decals21
  - Safety Alert Symbol21
  - Care of DANGER, WARNING and CAUTION Decals21
2. SERVICE THE TRACTOR27
3. SPECIFICATIONS29
- Specifications Table29
- Traveling Speeds30
4. IMPLEMENT CAPACITIES31
5. NAMES AND FUNCTIONS OF COMPONENTS33
- Overview33
  - Names of Main Components33
  - Functions of Main Components34
- Operator Station Controls35
  - Names of Components35
  - Function of Components36
- Instrument Panel44
6. PRE-OPERATION CHECK46
- Pre-Operation Check46
- Precautions Before Operation46
- Routine Checks46
- Prevent Damage to Plastic Surfaces and Painted Surfaces46
7. OPERATE THE ENGINE47
- Start the Engine47
- Start the Engine in Cold Weather53
- Shut Off the Engine53
- Restart a Stalled Engine54
- Start When the Engine Runs Out of Fuel55
8. OPERATE THE TRACTOR56
- Accident Hazard56
- Operate a New Tractor57
  - Always run the tractor at less than full speed during the first 50 hours of operation57
  - Change the lubricating oil for the new tractor57
- Raise and Lower the Roll-Over Protective Structure (ROPS)58
  - Lower (folded "down") the Roll-Over Protective Structure (ROPS)58
  - Raise (unfolded "up") the Roll-Over Protective Structure (ROPS)59
- Operate the Tractor60
- Stop the Tractor66
  - Stopping Procedure66
  - Stop in an Emergency67
- Use the Brake68
- Practices for Safe Operation69
9. POWER TAKE OFF (PTO) SYSTEM75
- Operate the Power Take Off (PTO) System75
- Use the Power Take Off (PTO) Safely78
  - Use the Power Take Off (PTO) Shaft Cap78
- Install an Implement to the Power Take Off (PTO) Driveline79
10. 3-POINT HITCH AND DRAWBAR80
- 3-Point Hitch80
- Drawbar85
- Use the Safety Chain86
11. HYDRAULIC SYSTEM88
- 3-point Hitch Control System88
- Operate the Implement Control Valve90
12. TYRES, WHEELS AND WEIGHT94
- Tyres94
- Adjust the Wheel95
- Remove/Install the Wheels97
- Weight (Option)97
13. MAINTENANCE101
- Maintenance Check List101
- Diesel Fuel Specifications103
- Lubricants104
- Replacement Parts105
  - Technical Document105
  - Parts105
14. PERIODIC SERVICE106
- Explosion Hazard106
- n Service the Tractor106
- n Warranty and Repair of the Engine106
  - NEVER inhale the engine exhaust gas.107
- Open/Close the Hood107
  - Open the Hood107
  - Close the Hood108
- Daily Checks108
- Check and Replace as Necessary120
- First 50 Hours121
- Every 50 Hours121
- Every 100 Hours126
  - Service the Air Cleaner Element126
  - Clean the Fuel/Water Separator and Replace the Fuel Filter128
- Every 200 Hours129
- Every 300 Hours131
  - Transmission Hydraulic Oil131
  - Change the Transmission Hydraulic Oil and Replace the Transmission Hydraulic Oil Filters and Clean Transmission Hydraulic Oil Strainer131
- Every 500 Hours133
- Every 1000 Hours136
- Every 1 Year139
  - Replace the Air Cleaner Element139
- Every 2 Years or 2000 Hours139
  - Replace the Thermostat139
- General Maintenance139
15. SERVICE THE ELECTRICAL SYSTEM140
- Battery140
- Fuses143
  - Replace the Accessory Fuses143
  - Check the Alternator Fuse and the Main Fuse143
- Bulb144
- Headlights146
  - Adjust the Headlights146
16. STORAGE147
- Safe Practices for Storage147
- Prepare the Stored Tractor for Operation148
17. TROUBLESHOOTING149
- How to Use the Troubleshooting Table149
18. INDEX160

Related product manuals

Preview: Yanmar EF-494T

Preview: Yanmar YM195

Preview: Yanmar YT235

Preview: Yanmar SA221

Preview: Yanmar YM155d

Preview: Yanmar YT3 Series

Yanmar YT3 Series