York Affinity DNP060 User Manual

CONTENTS
INSTALLATION SAFETY INFORMATION . . . . . . . . 4
GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
RENEWAL PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . 4
APPROVALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
SEQUENCE OF OPERATION. . . . . . . . . . . . . . . . . 17
START-UP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
TYPICAL WIRING DIAGRAM NOTES . . . . . . . . . . 37
NOTES, CAUTIONS AND WARNINGS
Installer should pay particular attention to the words: NOTE,
CAUTION, and WARNING. Notes
are intended to clarify or
make the installation easier. Cautions
are given to prevent
equipment damage. Warnings
are given to alert installer
that personal injury and/or equipment damage may result if
installation procedure is not handled properly.
INSTALLATION
MANUAL
CAUTION: READ ALL SAFETY GUIDES BEFORE YOU
BEGIN TO INSTALL YOUR UNIT.
SAVE THIS MANUAL
AFFINITY™ SERIES
SINGLE PACKAGED GAS/ELECTRIC
AIR COOLED AIR CONDITIONERS
2, 2-1/2, 3, 3-1/2, 4 AND 5 NOMINAL TON
DNP024, 030, 036, 042, 048 & 060
280241-YIM-D-0909

York Affinity DNP060 Specifications

General

Brand	York
Model	Affinity DNP060
Category	Air Conditioner
Language	English

Summary

Important Notes, Cautions, and Warnings

Installation Safety Information

Installation Limitations and Location

Installation Limitations

Requirements for installation according to codes.

Control Wiring Diagrams

Single Stage Thermostat Control Wiring

Diagram for single stage thermostat to single stage gas heat.

Two Stage Thermostat Control Wiring

Diagram for single stage thermostat to two stage gas heat.

Compressor Mounting and Power Wiring

Typical Field Power Wiring Diagram

Diagram showing single and three phase power wiring.

Gas Piping and Connection

Gas Piping Sizing

Sequence of Operation - Heating

Heating Sequence Steps

Describes pressure switch proving, pre-purge, ignition trial, and pilot stabilization.

Main Burner Operation

Sequence of Operation - Safety and Lockout

Lockout Conditions

Safety Controls

Details of limit switch, rollout switch, and flame sensor.

Sequence of Operation - Cooling and Start-Up

Cooling Sequence

Start-Up Procedures

Pre-start checklist and operating instructions.

Gas Valve Adjustment and Checks

Manifold Gas Pressure Adjustment

Checking Gas Input

Natural Gas Input Check

Steps to measure gas consumption using a meter.

Typical Wiring Diagram Interpretation

Typical Wiring Diagram Notes

General notes on field wiring and wire replacement.

Wiring Diagram Legend