JOHNSON CONTROLS
3
FORM 102.20-FA1 (LS01)
Continued on next page
PART
NUMBER
DESCRIPTION WHERE USED
GASKETS
028-11860-010 Gasket, Neoprene, Closed Cell, 1/2" W x 1/4"
Thk
Indoor unit raceway channel (sides, ends & vertical)
028-11873-010 Gasket, Neoprene, Closed Cell, Grey, 3/4" W
x 1/4" Thk
Panel to panel (vertical) on flange
028-11864-010 Gasket, Neoprene, Closed Cell, 3/4" W x 1/2"
Thk
Between vertical bulkheads and wall panels; between
horizontal bulkheads and roof/floor panels
028-11778-010 Gasket, Neoprene, Closed Cell, 1-1/4" W x
1/4" Thk
Shipping split, bottom, sides, top panel to panel ends butt
to butt
028-11867-010 Gasket, Neoprene, Closed Cell, 1-1/4" W x
1/2" Thk
Type 8 filter tracks under the bulkhead
028-11880-010
Gasket, Neoprene, Closed Cell, 2” W x 3/16”
(.188) Thk
Under roof seam cap, under roof overhang at pipechase,
on pipe chase (field applied)
28-11883-010 Gasket, Corner, Neoprene, Closed Cell, 3-1/2"
W x 1/4" Thk x 3-1/2" Lg.
XTO shipping splits
028-11791-010 Gasket, Polyurethane, Open Cell, 1" W x 1"
Thk
Filters, between roof panels
028-11882-010 Gasket, Foam, Closed Cell, Black, 2-1/2" W x
1/8" Thk
All electrical panels, to seal the conduit penetrations
between them and the unit wall panels, intermediate drain
pan mounting
AJ4144 Gasket, Door, 12' Lg. Foam gasket - new cake pan doors (beginning Jan 2006)
AJ3122 Gasket, Door, 500' Roll Foam gasket - old doors (before Jan 2006)
028-11865-010 Foam, #2 Polyester, Open Cell, 2" W x 2" Thk
x 4" Lg.
Wireway at pressure transitions
TAPES
013-02978-010 Tape, Butyl, 1/2" W x 1/8" Thk Outdoor unit doors along sides when door is between two
panels
013-02979-010 Tape, Butyl, 1/2" W x 1/4" Thk Outdoor units, between raceway 11/16" flanges and roof
013-02976-010 Tape, Butyl, 3/4" W x 3/16" Thk Outdoor units, between raceway 11/16" flanges and
panels/roof/drain pan/pipe chase/control enclosure, panel
to panel (vertical)
013-02977-010 Tape, Butyl, 1-1/2" W x 1/8" Thk Outdoor units, between top raceways & along roof sides
& between bottom raceways & curb rest
028-11879-010 Tape, Stainless Steel, 2” W x 0.004” Thk, 50'
Roll
Factory floor seam cap (interior of unit)
028-11879-012 Tape, Stainless Steel, 3” W x 0.004” Thk, 50'
Roll
Factory roof seam cap (exterior of unit)
010-02917-000 Ins Therm 1/8" x 1-1/2" x 50', White Ethafoam,
Marriage Tape
Coil, bulk head seal
Table 2 - Gasket/Caulk/Adhesive/Grommet for Solution Units
FIELD SERVICE PARTS
To Next Page
Loading...
