Airxcel 8330 series User Manual

2
TABLE OF CONTENTS
Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Package Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Ceiling Plenum Installation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Supply Ducting and Registers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Routing Thermostat Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Routing 115 VAC Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Ceiling Plenum Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Connect 115 VAC Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Connect Thermostat Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Install Air Grille Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
WARNINGS
IMPORTANT NOTICE
These instructions are for the use of qualified individuals
specially trained and experienced in installation of this type
equipment and related system components.
Installation and service personnel are required by some states
to be licensed. PERSONS NOT QUALIFIED SHALL NOT
SERVICE THIS EQUIPMENT.
WARNING
Improper installation may damage equipment, can create a
hazard and will void the warranty.
The use of components not tested in combination with these
units will void the warranty, may make the equipment in
violation of state codes, may create a hazard and may ruin the
equipment.
WARNING – SHOCK HAZARD
To prevent the possibility of severe personal injury or
equipment damage due to electrical shock, always be sure the
electrical power to the appliance is disconnected during
installation.
CAREFULLY FOLLOW ALL INSTRUCTIONS AND
WARNINGS IN THIS BOOKLET TO AVOID DAMAGE
TO THE EQUIPMENT, PERSONAL INJURY OR FIRE.
NOTE
The words “Shall” or “Must” indicate a
requirement which is essential to
satisfactory and safe product performance.
The words “Should” or “May” indicate a
recommendation which is not essential
and not required but which may be useful
or helpful.
PACKAGE CONTENTS
1) Wirebox Assembly
1) Duct Divider Board – Some models do not have
Divider Boards (boards are provided bulk packed)
1) Insulated Duct Locator Plate
1) Air Grille Assembly
1) Installation Instructions
1) Mount Frame
1) Small Parts Package Consisting Of:
4) Bolts
4) Screws – 3/8” Length
1) Strain Relief
2) Metal Wing Nuts
3) Wire Nuts
3) Screws – 3/4" Length
1) Evaporator Freeze Sensor

Airxcel 8330 series Specifications

General

Brand	Airxcel
Model	8330 series
Category	Air Conditioner
Language	English