Akron 6032 - Page 3

3
LIST OF ILLUSTRATIONS
Figure 1-1 Universal II Control Box ............................................
Figure 2-1 Universal II Mounting Hole Locations ...............................
Figure 2-2 Monitor Connector (Looking into Universal II) .......................
Figure 2-3 DC Power/Signal Connector (Looking into Universal II) ..............
Figure 2-4 Vehicle Battery Connection ........................................
Figure 2-5 Logic Output Wiring ...............................................
Figure 2-6 Relay Contact Output Wiring ......................................
Figure 2-7 Switch Input Wiring ...............................................
Figure 2-8 Operator Interface Wiring .........................................
Figure 2-9 J1939 CAN Wiring .................................................
LIST OF TABLES
Table 2-1 Tools and Materials Required for Installation ..........................
Table 2-2 Monitor/Turret Connector Pin-out ..................................
Table 2-3 Generic DC Power/Signal Connector Pin-out .........................
Table 2-4 Maximum power wire lengths without Auxiliary battery ...............
Table 3-1 Setup mode LED codes ..............................................
4. MAINTENANCE AND SERVICE INSTRUCTIONS.........
4.1 Maintenance Instructions..............................
4.2 Troubleshooting Electrical.............................
4.2.1 Operating Environment...............................
4.2.2 Common Electrical Issues.............................
5. CAN MESSAGING..........................................
5.1 CAN Address Claimingt..................................
5.1.1 Prerequisite Knowledge................................
5.1.2 CAN Physical Layert....................................
5.1.3 Address Claimingt......................................
5.1.4 General Message Characteristics. . . . . . . . . . . . . . . . . . . . .
Appendix A Address Claiming..............................
Appendix B Joystick Data...................................
6. UNIVERSAL II VARIANT DETAILS.........................
6.1 60320004.................................................
6.2 60320006.................................................
6.3 60320008.................................................
6.4 60320010.................................................
6.5 60320012.................................................
6.6 60320014.................................................
6.7 60320016.................................................
6.8 60320018.................................................
6.9 60320020.................................................
6.10 60320022.................................................
7. REVISIONS..................................................
6
9
10
11
13
13
14
14
15
16
8
10
12
13
13