Alfa Laval LKHP - Default Chapter; Table of Contents

Table of contents
The information herein is correct at the time of issue but may be subject to change without prior notice
1. EC Declaration of Conformity ....................................................................... 4
2. Safety .................................................................................................... 5
2.1. Important information .............................................................................
5
2.2. Warning signs .....................................................................................
5
2.3. Safety precautions ................................................................................
6
3. Installation .............................................................................................. 7
3.1. Unpacking/delivery ...............................................................................
7
3.2. Installation .........................................................................................
8
3.3. Pre-use check - pump without/with impeller screw ...........................................
9
3.4. Recycling information .............................................................................
10
4. Operation ............................................................................................... 11
4.1. Operation/control .................................................................................
11
4.2. Fault finding .......................................................................................
13
4.3. Recommended cleaning .........................................................................
14
5. Maintenance ........................................................................................... 15
5.1. General maintenance .............................................................................
15
5.2. Cleaning Procedure ...............................................................................
16
5.3. Dismantling of pump/shaft seals ................................................................
17
5.4. Assembly of pump/shaft seal ....................................................................
20
6. Technical data ......................................................................................... 23
6.1. Technical data .....................................................................................
23
6.2. Relubrication intervals ............................................................................
25
7. Parts list and service ki
ts ............................................................................
27
7.1. LKHP Filtration Centrifugal Pump for High Inlet Pressure .....................................
27
7.2. LKHPF - Wet end .................................................................................
28
7.3. LKHPF - Mortor dependent parts ...............................................................
30
7.4. LKHPF - Shaft seals ..............................................................................
32
3