Weekly:
1. Check overall condition of the treadmill.
2. Inspect the fabric enclosure for tears or leaks.
3. Wipe down exterior surfaces with a damp cloth. A mild soap solution can be
used. IMAR™
4
Strataglass Cleaner is recommended for cleaning the clear
windows.
4. Clean the control console with a mild soap solution to remove grime.
5. Vacuum the interior of the fabric enclosure through the access hole in the top.
You can position the cockpit in the highest position and crawl inside for better
access.
6. Check shorts for rips or holes.
Monthly:
Perform weekly maintenance items and in addition do the following:
1. Feel the surface of the deck under the tread belt. It should feel slick and slightly
moist with lubricant. If there is debris accumulation or if it is dry or tacky perform
the following:
o Wipe the deck and underside of the tread belt with a clean towel. Rotate
the belt to expose the remaining section and wipe again.
o Apply one 1 ounce packet of SlipCoat
5
under the tread belt. Walk for one
minute on the treadmill at a low speed to disperse the lubricant. SlipCoat
is very slippery. If you get it on the top surface of the belt or railings, clean
with rubbing alcohol and a sponge.
SlipCoat may be found online or you can order directly from AlterG.
Annually:
Note: AlterG recommends that you have a qualified technician
perform the annual maintenance.
1. Perform the following procedures annually:
- Inspect all nuts and bolts. Tighten any that are loose.
- Clean the running surface, if necessary use a bristle brush to remove
heavy grime.
- Check and adjust tread belt alignment if needed.
- Wipe down the treadmill deck under the tread belt.
- Lubricate the treadmill deck with SlipCoat.
- Vacuum under the treadmill motor cover.
- Adjust the drive belt tension. Replace the belt if worn or damaged.
- Inspect the treadmill motor brushes and replace if worn below 3/8 inch.
Dress the commutator if needed.
''''''''''''''''''''''''''''''''''''''''''''''''''''''''
4
'IMAR'is'a'trademark'of'IMAR'Products,'LLC.''Manassas,'VA.'
5
'SlipCoat'is'a'product'of'Landice'Inc.,'Randolph,'New'Jersey.'
To Next Page
