Amana APG M Series User Manual

38
WARNING
HIGH VOLTAGE
'එඛඋ඗ඖඖඍඋගඉඔඔ඘඗ඟඍකඊඍඎ඗කඍඛඍකඞඑඋඑඖඏ඗ක
එඖඛගඉඔඔඑඖඏගඐඑඛඝඖඑග0ඝඔගඑ඘ඔඍ඘඗ඟඍකඛ඗ඝකඋඍඛ
ඕඉඡඊඍ඘කඍඛඍඖග)ඉඑඔඝකඍග඗ඌ඗ඛ඗ඕඉඡඋඉඝඛඍ
඘ක඗඘ඍකගඡඌඉඕඉඏඍ඘ඍකඛ඗ඖඉඔඑඖඒඝකඡ඗කඌඍඉගඐ
5ඍ඘ඔඉඋඍ඗ක&ඔඍඉඖ)එඔගඍක
,03257$17127(1ඍඞඍක඗඘ඍකඉගඍඝඖඑගඟඑගඐ඗ඝගඉ
ඎඑඔගඍකඑඖඛගඉඔඔඍඌඉඛඌඝඛගඉඖඌඔඑඖගඟඑඔඔඊඝඑඔඌඝ඘඗ඖ
එඖගඍකඖඉඔ඘ඉකගඛකඍඛඝඔගඑඖඏඑඖඔ඗ඛඛ඗ඎඍඎඎඑඋඑඍඖඋඡ
ඍ඙ඝඑ඘ඕඍඖගඌඉඕඉඏඍඉඖඌ඘඗ඛඛඑඊඔඍඎඑකඍ
$UHWXUQDLU¿OWHULVQRWVXSSOLHGZLWKWKLVXQLWKRZHYHUWKHUH
PXVWEHDPHDQVRI¿OWHULQJWKHUHWXUQDLU$QLQGRRUDLU¿OWHU
must be used with your comfort system. A properly maintained
¿OWHUZLOONHHSWKHLQGRRUFRLORI\RXUFRPIRUWV\VWHPFOHDQ$
dirty coil could cause poor operation and/or severe equipment
damage.
7KHLQVWDOOHURI\RXUXQLWFDQWHOO\RXZKHUH\RXU¿OWHUVDUH
and how to clean or replace them.
&KHFN\RXUUHWXUQ¿OWHUVDWOHDVWRQFHHYHU\WZRPRQWKV
When they are dirty, replace or clean as required. Disposable
W\SH¿OWHUVVKRXOGEHUHSODFHG5HXVDEOHW\SH¿OWHUVPD\EH
cleaned.
127(5ඍඝඛඉඊඔඍගඡ඘ඍඎඑඔගඍකඛඛඐ඗ඝඔඌඊඍඟඉඛඐඍඌ
ඟඑගඐඟඉකඕඟඉගඍකඌකඑඍඌඋ඗ඕ඘ඔඍගඍඔඡඉඖඌඛ඘කඉඡඍඌ
ඟඑගඐඉඖඉඌඐඍඛඑඞඍඉඋඋ඗කඌඑඖඏග඗ගඐඍඕඉඖඝඎඉඋගඝකඍකඛ
කඍඋ඗ඕඕඍඖඌඉගඑ඗ඖඛ
<RXPD\ZDQWWRDVN\RXUGHDOHUDERXWKLJKHႈFLHQF\¿OWHUV
+LJKHႈFLHQF\¿OWHUVDUHDYDLODEOHLQERWKHOHFWURQLFDQG
QRQHOHFWURQLFW\SHV7KHVH¿OWHUVFDQGRDEHWWHUMRERIFDWFK-
ing small airborne particles.
,PSURSHU¿OWHUPDLQWHQDQFHLVWKHPRVWFRPPRQFDXVHRI
inadequate heating or cooling performance. Filters should be
FOHDQHGSHUPDQHQWRUUHSODFHGGLVSRVDEOHHYHU\WZRPRQWKV
RUDVUHTXLUHG:KHQUHSODFLQJD¿OWHULWPXVWEHUHSODFHGZLWK
D¿OWHURIWKHVDPHW\SHDQGVL]HDQGDOZD\VPDNHFHUWDLQWKH
DLUÀRZDUURZVRQWKH¿OWHUSRLQWLQWKHSURSHUGLUHFWLRQ
&඗ඖඌඍඖඛඍක(ඞඉ඘඗කඉග඗කඉඖඌ,ඖඌඝඋඍඌ'කඉඎග0඗ග඗කඛ
The bearings on the air circulating blower motor, condenser
motor and the combustion fan motor are permanently lubricat-
ed and require no further lubrication.
&඗ඕ඘කඍඛඛ඗ක
The compressor motor is hermetically sealed and does not
require additional oiling.
$ඖඖඝඉඔ,ඖඛ඘ඍඋගඑ඗ඖ4ඝඉඔඑඎඑඍඌ6ඍකඞඑඋඍක2ඖඔඡ
<RXUSDFNDJHXQLWVKRXOGEHLQVSHFWHGE\DTXDOL¿HGLQVWDOOHU
or service agency at least twice every year. This check should
be performed before the heating and cooling seasons begin.
This will ensure that adequate combustion air is being drawn
and the vent system is working properly. Particular attention
should be paid to the following items. Repair as necessary.
• Check physical support of the unit. Ensure it is sound
without any sagging, cracks, or gaps, around the base.
• Check for obvious signs of deterioration of the unit.
• Flue Hood and Combustion Air Inlet. Check for blockage
ZDVSQHVWHWFDQGFRUURVLRQ
)ඔඝඍ+඗඗ඌ4ඝඉඔඑඎඑඍඌ6ඍකඞඑඋඍක2ඖඔඡ
• Return Air Connection. Check for physical soundness
DQGHQVXUHWKDWWKHFRQQHFWLRQLV¿UPO\VHDOHGWRWKH
package unit casing.
• Heat exchanger. Check for corrosion and/or obstructions
within the heat exchanger passageways.
• Burners.&KHFNIRUSURSHULJQLWLRQEXUQHUÀDPHDQG
ÀDPHVHQVH
• Wiring. Check wires for damage. Check electrical
connections for tightness and/or corrosion.
• Filters.&KHFNWKDW¿OWHUVDUHFOHDQDQGLQWKHSURSHU
placement in the unit or duct system.
• Louvers. Inspect air inlet louvers inside the heat
exchanger compartments. Ensure the area is clean and
free of dirt and debris.
&ඔඍඉඖ2ඝගඛඑඌඍ&඗එඔ4ඝඉඔඑඎඑඍඌ6ඍකඞඑඋඍක2ඖඔඡ
The outdoor coil should be inspected annually. It is important
to keep the outdoor coil clean. Dirt, leaves, or debris could
UHVWULFWWKHDLUÀRZ,IFOHDQLQJRIWKHRXWGRRUFRLOEHFRPHVQHF-
HVVDU\KLUHDTXDOL¿HGVHUYLFHU,QH[SHULHQFHGSHRSOHFRXOG
easily puncture the tubing in the coil.
:HVWURQJO\UHFRPPHQGDELDQQXDOPDLQWHQDQFHFKHFNXSEHSHUIRUPHG
E\DTXDOL¿HGVHUYLFHDJHQF\EHIRUHWKHKHDWLQJDQGFRROLQJVHDVRQVEHJLQ
PACKAGE UNITS - DUAL FUEL & GAS
+20(2:1(5¶65287,1(0$,17(1$1&(5(&200(1'$7,216
• Check the thermostatWRFRQ¿UPWKDWLWLVSURSHUO\VHW
• Check the disconnectVZLWFKQHDUWKHXQLWWRFRQ¿UP
that it is closed.
• Check the electrical panel for tripped circuit breakers
or failed fuses. Reset the circuit breakers or replace
fuses as necessary.
• Check for blockage of the indoor air inlets and
outlets. &RQ¿UPWKDWWKH\DUHRSHQDQGKDYHQRWEHHQ
EORFNHGE\REMHFWVUXJVFXUWDLQVRUIXUQLWXUH
• Check for obstructions on the unit.&RQ¿UPWKDWLWKDV
not been covered on the sides or the top. Remove any
obstruction that can be safely removed. If the unit is
FRYHUHGZLWKGLUWRUGHEULVFDOODTXDOL¿HGVHUYLFHUWR
clean it.
• &KHFNWKH¿OWHU If it is dirty, clean or replace it.
%ඍඎ඗කඍ&ඉඔඔඑඖඏ<඗ඝක6ඍකඞඑඋඍක

Amana APG M Series Specifications

General

Brand	Amana
Model	APG M Series
Category	Air Conditioner
Language	English