EasyManua.ls Logo

Astralpool BPM800A - User Manual

Astralpool BPM800A
28 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
17/07/2013
INSTALLATION AND
OPERATING INSTRUCTIONS
Melbourne: 03 8796 8600 Gold Coast: 07 5552 2600 Perth: 08 9350 2600
Sydney: 02 9853 2100 Townsville: 07 4750 3100 sales@astralpool.com.au
Brisbane: 07 3308 5400 Adelaide: 08 8152 7600 www.astralpool.com.au
Bolero ND
Cleaner
INSTALLATION AND OPERATING INSTRUCTIONS I INSTALLATION AND OPERATING INSTRUCTIONS
Astral Heat
Pumps

Table of Contents

Questions and Answers

  • S
    Stephen LoweAug 6, 2025
    How to troubleshoot an Astralpool BPM800A Heat Pump that will not start?
    • B
      Barbara VasquezAug 6, 2025
      If your Astralpool Heat Pump isn't starting, begin by ensuring the power to the heater is on and the pump is running. If the pump isn't running, start it. Check for any leaks or issues with the non-return valve if the pump is airlocked. Also, verify the filter is clean and the pump strainer basket isn't clogged. If the heater control is defective, shut off the electrical supply and call for service. Ensure the thermostat is on and set to the correct setpoint, adjusting the set temperature as needed based on the water temperature. If a fault condition is displayed due to the water being too hot, refer to the fault indication table.
  • J
    Jimmy DunlapAug 21, 2025
    Why is my Astralpool BPM800A Heat Pump short cycling?
    • K
      Katrina Cook DVMAug 21, 2025
      Short cycling (rapid on and off operation) in your Astralpool Heat Pump can be due to several reasons. First, check for insufficient water flow by cleaning the filter and pump strainer. Second, defective wiring can cause this issue, so repair or replace the wiring if needed. Finally, a defective high limit or thermostat could be the culprit, requiring repair or replacement.

Summary

Introduction

Notice to Installers

Guidance for authorized personnel on appliance installation and compliance with regulations.

Safety Rules

Essential safety precautions for users regarding water temperature, health, and medication.

Operating Instructions

Step-by-step guide for operating the heat pump, including pump activation and thermostat settings.

Operation

Chemical Balance

Maintaining correct chemical balance in pool/spa water to prevent heater corrosion and voiding warranty.

Technical Specifications

Detailed specifications for various Astral Pool Heat Pump models, including capacity, efficiency, and dimensions.

Digital Thermostat Operation

Explanation of the NA6888 controller's functions, display, and operation modes.

Maintenance

Maintenance Instructions

Recommended checks and cleaning for the heat pump every six months and at the start of each season.

Energy Saving Tips

Advice on reducing heating costs and optimizing heat pump efficiency through usage and settings.

Winter Operation

Procedures for operating or shutting down the heat pump during winter or periods of non-use to prevent freezing.

Installation

Flow Rates

Required water flow rates for the heat pump and adjustment procedures using the unit's gauge.

Water Connections

Guidelines for connecting the heat pump to the filtration circuit and sanitiser placement.

Clearances

Minimum required air flow clearances around the heat pump for proper operation and ventilation.

Electrical Connection

Requirements for electrical installation by a licensed electrician, including safety switches and RCDs.

Guide to Heat Pump Noise

Information on managing heat pump noise levels and determining safe distances to neighbours.

Troubleshooting

Heater Will Not Start

Common causes and remedies for the heat pump failing to start operation.

Heater Short Cycling

Troubleshooting steps for rapid on and off cycling of the heat pump, indicating potential issues.

Warranty

Warranty Terms and Conditions

Details of the heat pump warranty, including covered parts, periods, exclusions, and claim procedures.

Astralpool BPM800A Specifications

General IconGeneral
BrandAstralpool
ModelBPM800A
CategoryHeat Pump
LanguageEnglish

Related product manuals