- 24 -
Maintenance
Use of Service Paks
Service Paks include all genuine parts needed for normal
maintenance of both compressor and engine. Service Paks
minimize downtime and keep your maintenance budget
low. You may order Service Paks from your local Atlas
Copco dealer.
Preventive Maintenance Schedule For
The Compressor
The schedule contains a summary of the maintenance
instructions.
Read the respective section before taking maintenance
measures.
When servicing, replace all disengaged packings, e.g.
gaskets, 0-rings, washers.
For engine maintenance refer to Engine Operation
Manual.
The maintenance schedule has to be seen as a guideline for
units operating in a duty environment typical to
compressor applications. Maintenance schedule can be
adapted depending on application environment and
quality of maintenance
• When the battery is used for less than 100 hours in a
year, check its electrolyte yearly. (for refillable bat-
tery's only)
• When biodiesel fuel is used, change the fuel filter
cartridge, fuel hose and clamp bands with new ones
at intervals half of the usual ones.
• Consult your local KUBOTA dealer for this service.
• The items in the engine manual are registered as
emission related critical parts by KUBOTA in the
U.S. EPA nonroad emission regulation. As the engine
owner, you are responsible for the performance of the
required maintenance on the engine according to the
above instruction. Please see the warranty statement
in detail.
• The items listed above are not necessary to keep the
emission-related warranty valid.
MAINTENANCE SCHEDULE Daily Initial 50 hours + Every
250/750 hours
1310 9230 21
Every 500 hours / Bi-
yearly
1310 9230 22
Every 1000 hours /
Yea r ly
1310 9230 23
Note
Check of fuel level Check
Check of coolant level Check
Check of fan belt Check Change Change
Change of engine oil Check level Change Change Change See change interval
Replacement of engine oil filter cartridge Initial 50 hr replace Replace with oil change Replace with oil change
Replacement of fuel pre-filter Replace Replace Replace
Replacement of Compressor oil filter Replace Replace
Change of Compressor oil Check level Change Oil not included
Change Air filters Change Change
Torque Wheel nuts Check Check Check
Tire pressure Check Check Check
Safety Valve Test
Shutdown switches Check
Oil Separator Filter Change
Replacement of final fuel filter cartridge Initial 50 hr replace Replace Replace Every 400 hours
Cleaning of water jacket and radiator interior Check Check
Check of valve clearance Check
To Next Page
Loading...
Need help?
General
