4-14
Care and Maintenance
PROBLEM POSSIBLE CAUSE SOLUTION
Engine will not turn • Throttle control in gear. • Shift into neutral.
over • Main circuit breaker open. • Reset circuit breaker.
• Weak or dead battery. • Charge or change battery.
• Poor or loose battery • Clean and tighten battery
connections. cable connections.
Engine turns over, but • No fuel in tanks. • Fill fuel tank.
will not start • Contaminated Fuel. • See your dealer.
• Distributor Problems. • See your dealer.
Engine is hard to start • Flooded engine. • Start engine full throttle
and back off.
• Plugged flame arrestor. • Clean flame arrestor.
• Fouled spark plugs. • Replace spark plugs.
• Loose coil or ignition wires. • Tighten coil or ignition
wires.
• Battery cables loose or • Clean and tighten battery
corroded. cables.
• Weak battery. • Charge or replace the
battery.
• Ignition problems. • See your dealer.
Engine misses or • Fouled spark plugs. • Replace spark plugs.
idles rough • Loose of defective high- • Tight or replace the high-
tension leads. tension leads.
• Plugged PCV valve. • Replace PCV valve.
• Weak ignition coil. • Replace ignition coil.
• Vacuum leak. • See your dealer.
Poor boat performance • Fouled spark plugs. • Replace spark plugs.
• Plugged flame arrestor. • Clean the flame arrestor.
• Weak ignition coil. • Replace the ignition coil.
• Contaminated fuel. • See your dealer.
• Fuel filter clogged. • See your dealer.
• Ignition problems. • See your dealer.
Poor gas mileage • Fouled spark plugs. • Replace spark plugs.
• Plugged flame arrestor. • Clean the flame arrestor.
• Inefficient driving habits. • Plan the boat quickly, then
slow down to desired speed.
• Plugged PCV valve. • Replace PCV valve.
• Ignition problems. • See your dealer.
Chapter 4_15_Axis.qxp_ Chapter 4 doc.qxd 6/19/14 10:32 AM Page 14
To Next Page
Loading...
Need help?
General
