Aztec EDGEWINDER - ENGINE TROUBLESHOOTING GUIDE; ENGINE STARTING AND RUNNING ISSUES; ENGINE OVERHEATING AND EMISSION PROBLEMS

To Order Parts Call 1-888-702-5326 - https://monsterfloorequipmentparts.com
EDGEWINDER OWNER’S MANUAL PAGE 24
05-2017
ENGINE TROUBLESHOOTING
COMMON PROBLEMS & PROBABLE CAUSES
SOLUTIONS *
ENGINE WILL NOT START:
Check battery
Check engine oil
Remove and inspect spark plug
Take engine to an authorized HONDA servicing dealer
Battery may be discharged; recharge battery
Engine oil level may be low; fill with recommended
oil to the proper level (see pgs 16-19)
Spark plug may be faulty, fouled, or improperly
gapped; correct the gap or replace spark plug (see
pg 21)
May be a regulator malfunction, ignition malfunction,
valves stuck, etc; replace or repair faulty
components as necessary
ENGINE CRANKS BUT WILL NOT START:
Fuel cylinder is empty
Shutoff valve is closed
Clogged, obstructed, kinked or cut fuel or vacuum line
Spark plug lead disconnected
Faulty choke or throttle settings
Faulty ignition coil
Faulty kill switch
Faulty regulator
Refill cylinder
Open valve
Remove obstruction or replace line
Connect lead to spark plug
Set controls to correct positions
Replace coil
Replace switch
Replace regulator
ENGINE STARTS HARD:
Faulty choke or throttle settings
Clogged, obstructed, kinked or cut fuel or vacuum line
Faulty regulator
Low compression
Set controls to correct position
Remove obstruction or replace line
Replace regulator
Take engine to an authorized HONDA servicing
dealer
ENGINE WILL NOT CRANK:
Battery is discharged
Loose or faulty connections or wires
Faulty ignition key switch or starter control switch
Charge or replace battery
Tighten, repair or replace wires
Repair or replace switch(es)
ENGINE OVERHEATS:
Incorrect fuel settings
Air intake filter screen or cooling fins clogged
Low oil level
Have engine serviced
Clean and clear debris or replace filter
Check and add oil
EXHAUST EMISSIONS OR EXHAUST ODOR
Regulator setting incorrect
Dirty or clogged air filter
Loose fittings, clamps or hoses cracked, hoses cut or
leaking
Have engine serviced
Replace air filter
Tighten or seal; check with soap and
ENGINE LACKS POWER:
Check air filter
Take engine to an authorized HONDA servicing
dealer
Filter elements may be restricted; clean or replace
filter elements (see pg 20)
May be a regulator malfunction, ignition malfunction,
valves stuck, etc; replace or repair faulty
components as necessary
* Remember that an authorized HONDA servicing dealer knows your engine best and is fully equipped to maintain and
repair it. To ensure the best quality and reliability, use only new genuine Honda parts or their equivalents for repair and
replacement.