Bad Boy 550cc - Every 200 Hours; Changing Engine Oil; Replacing Engine Oil Filter

Periodic Service
10-15
IMPORTANT:

Visually check the muffler for cracks or holes
in the body, weldment or pipes at regular
intervals.
 USDA approval requires clearance
between spark arrester sleeve and muffler
body to be no larger than 0.023”(0.584
mm).
 Replace the entire muffler if it is damaged.
 Do not operate the vehicle with
a
d
amaged muffler.
① Muffler ② Spark arrester
EVERY 200 HOURS
■ Changing Engine Oil
CAUTION
To avoid personal injury:
 Be sure to stop the engine before
replacing oil.
 Allow engine to cool down sufficiently,
oil can be hot and can
burn.
1. Park the vehicle on flat surface and raise
the cargo bed.
2.
To drain the used oil, remove the
drain
pl
ug at the bottom of the engine and
completely drain the oil into an oil pan.
3. After draining, reinstall the drain plug.
4. Fill with the new oil up to the upper notch
on the dipstick.
(See “LUBRICANTS, FUEL AND
COOLANT” in “MAINTENANCE” section.)
Oil capacity
with filter change 2.0L (2.2U.S. qts.)
without filter change 1.8L (1.89U.S. qts.)
① Dipstick
② Oil Level
5. See Figure for oil recommendations.
■ Replacing Engine Oil Filter
CAUTION
To avoid personal injury:
 Be sure to stop the engine before
changing the oil filter cartridge.
Allow engine to cool down sufficiently,
Oi
l can
be
hot and can burn
.
1. Park the vehicle on a flat surface, remove
the seat and open the adjust hatch cover.
2. Remove the oil filter.
3. Put a film of clean engine oil on the rubber
seal of the new filter.