BioCool BIO-30 DAV - Page 18

ECO Cooling Soluons INSTALLATION GUIDE
ENG
34
>
35
>
Aer each of the maintenance operations, a technical report on the condition of
the equipment is prepared so they may have a greater control of their installations.
This report would be aached to the Record Book of the installation for the control
of Legionnaire’s disease along with the certificate of cleaning and disinfection and
analytical results to comply with the regulations in force.
Point out that equipment have an automatic cleaning of tray and drain system .This
system will allow also leave the tray without water when the appliance is unused
during a season, reducing most if possible, the risk of proliferation of Legionnaire’s
disease to empty the tray both when the equipment is not used as when it reaches
high values of suspended solids.
Review the following points :
REVIEW POINTS:
• Draining and cleaning tray and equipment.
• Water pump.
• Automatic gate closure.
• External panels (housing evaporative panels)
• Evaporative cellulose filters.
• Review irrigation water (water dispenser)
• Eye examination of electrical lines, water and sanitation.
• Motor fan.
• Water detector.
• Solenoid electrovalve.
• Automatic drain w.
• Automatic filling.
OPENING AND SEASON CLOSURE
SEASON OPENING WORKS:
• Disconnect the power supply.
• Remove the filter panels to give access to the interior.
• Wash the filters to remove the dust accumulated during the winter. Change
filters if they are in bad condition.
• Turn on the electricity switch inside of the air conditioner.
• Connect the water supply and electrical supply.
• Put the filters panels to close the unit.
• Start-up of the air conditioner.
OPENING AND SEASON CLOSURE
SEASON CLOSURE WORKS
• Disconnect the power supply.
• Close the water supply.
• Remove the filter panels to give access to the interior.
• Disconnect the power switch inside of the air conditioner.
• Check and clean the guers of water from the tap.
• Allow water to drain from the tank through the drain valve that is automatic.
• Aer draining all the tank, clean the tank and the pump filter.
• Put the filter panels to close the unit