BOOM TRIKES V1 AUTOMATIC - Troubleshooting

32
4.9 T
ROUBLESHOOTING
SYMPTOM
POSSIBLE CAUSE
SOLUTION
ENGINE WILL NOT STAR
T
Handbrak
e on
Release handbrake
Fuse blown
Replace fuse and contact
specialist dealer
STARTING DIFFICULTIE
S
Fuel tank empty
Fill up with petrol
Fuel injection system
malfunction
Contact specialist dealer
Damaged petrol pump
Contact specialist dealer
Flat battery
Charge battery
LOW COMPRESSION
Defective spark plug
Replace spark plug
Defective electronic
management/ fuel
injection system
Always contact specialist dealer,
as safety risks are involved when
working on high voltage
Loose spark
plug
Tighten spark plug
Cylinder head not
tightened down properly,
worn piston rings,
Contact specialist dealer
sticking valves
HIGH PETROL CONSUMPT
ION
AND LOW ENGINE
PERFORMANCE
Air filter clogged
Clean with air hose, alternatively
replace.
INADEQUATE BRAKING
PERFORMANCE
Oil or grease on brake
discs. Worn brake
pads, braking system
malfunctioning.
Contact specialist dealer
POOR SPRINGING / DAM
PING
Defective or leaking
dampers, worn stop
rubbers, incorrect spring
pre-load
Contact s
pecialist dealer
PROBLEMS WITH AUTOMA
TIC
GEARBOX
Worn pulleys or drive
belt
Contact specialist dealer
IMPORTANT:
NEVER RUN THE VEHICLE UNTIL THE FUEL TANK IS COMPLETELY EMPTY. HOWEVER, IF THIS
OCCURS, DO NOT MAKE REPEATED ATTEMPTS AT STARTING THE ENGINE. TURN THE
IGNITION TO “OFF“ AND FILL UP WITH PETROL AS SOON AS POSSIBLE. FAILURE TO
OBSERVE THESE INSTRUCTIONS CAN LEAD TO THE FUEL PUMP AND/OR CATALYTIC
CONVERTER BEING DAMAGED BEYOND REPAIR.