47
8.0 M
AINTENANCE AND SERVICE INTERVALS
Maintenance should only be carried out by a specialist car dealer, a specialist motorcycle dealer (Piaggio or Aprilia)
or by an authorised BOOM dealer.
The following service instructions assume that the trike is used exclusively as the manufacturer originally intended.
If you ride it at consistently high engine speeds, or in unusually wet or dusty conditions, or rent the vehicle out, then
it will require attention at shorter intervals than those specified in the service booklet.
Your authorised BOOM TRIKES dealer will be able to advise you on an appropriate service itinerary for your trike.
Regular servicing will ensure that your trike maintains its value and roadworthiness. A worldwide network of over
100 BOOM Trikes dealers and several thousand car and motorcycle dealers is at your disposal to ensure that your
trike can always be properly maintained.
Check
Replace
x 1000 km 1 10
20
30
40
50 60
70 80
90 100
110
120
months
4 12
24
Engine oil Check oil
level / top up
EVERY 3000 km
Engine oil Change oil
Gearbox oil (Differential
gearbox)
Check oil
level / change
oil
Spark plug/ plug gap Check / replace
Air filter Replace / clean
Oil filter Replace
Petrol filter Check / replace
Valve clearances
0.15 mm (all valves)
Check
Petrol mixture Check / adjust
Seals, leaks from petrol
& brake lines, FI system
Visual chheck
Oil sump breather Visual check
Variators Replace
Curved track shoes Check / replace
Bush, driven belt pulley Check / grease
Drive belt Replace
Coolant level Check
Coolant Replace EVERY 2 YEARS
Radiator Clean exterior / check
Steering head bearings Check / grease
Oil pinion Replace
Brake pads Check condition and wear EVERY 3000 km
Brake fluid level Check
Brake fluid Replace EVERY 2 YEARS
Torque settings Check
Suspension, front and
rear, springs, dampers
Check
Fork oil (only telescopic
fork)
Check / replace
Electr. system, battery Check
Headlamps Check / adjust
Tyres Check pressures & tread wear
Vehicle and brake test Test ride
Throttle body Clean / adjust
Air filter CVT Clean
(For a list of recommended lubricants see page 1)
To Next Page
Loading...
