Carrier PREMIERLINK 33CSPREMLK - User Manual

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
PC 111 Catalog No. 533-80072 Printed in U.S.A. Form 38-54SI Pg 1 11-02 Replaces: 38-52SI
Book 1 4
Ta b 3 a 2a
Installation, Start-Up and
Configuration Instructions
Part Number 33
CSPREMLK
CONTENTS
Page
SAFETY CONSIDERATIONS
. . . . . . . . . . . . . . . . . . . . . . 1
GENERAL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1,2
INSTALLATION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-26
Inspection
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
PremierLink Controller Hardware
. . . . . . . . . . . . . . . . . 2
Field-Supplied Hardware
. . . . . . . . . . . . . . . . . . . . . . . . . 2
• SPACE TEMPERATURE (SPT) SENSOR
• SUPPLY AIR TEMPERATURE (SAT) SENSOR
• INDOOR AIR QUALITY CO
2
SENSOR
• OUTDOOR AIR QUALITY CO
2
SENSOR
• OUTDOOR AIR TEMPERATURE SENSOR
• OUTDOOR AIR ENTHALPY SWITCH
• RETURN AIR ENTHALPY SENSOR
Mount PremierLink Control
. . . . . . . . . . . . . . . . . . . . . . . 2
•LOCATION
• MOUNTING
PremierLink Controller Inputs and Outputs
. . . . . . 3
Control Wiring
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Install Sensors
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
• SPACE TEMPERATURE (SPT) SENSOR
INSTALLATION
• SUPPLY AIR TEMPERATURE (SAT) SENSOR
INSTALLATION
• INDOOR AIR QUALITY CO
2
SENSOR
INSTALLATION
• OUTDOOR AIR QUALITY CO
2
SENSOR
INSTALLATION
• OUTDOOR AIR TEMPERATURE SENSOR
Connect to CCN Communication Bus
. . . . . . . . . . . 18
• COMMUNICATIONS BUS WIRE SPECIFICATIONS
Enthalpy and Differential Enthalpy Control
. . . . . . 18
• ENTHALPY SWITCH/RECEIVER
• OUTDOOR AND RETURN AIR ENTHALPY
SENSOR
Economizer
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
• Q769B
• Q769C
Economizer with Johnson 4 to 20 mA
Actuator
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
• DRIVE DIRECTION
• SWITCH SELECTION
•WIRING
START-UP
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26-28
Perform System Check-Out
. . . . . . . . . . . . . . . . . . . . . 26
Initial Operation and Test
. . . . . . . . . . . . . . . . . . . . . . . . 26
Install Navigator™ Display Module
. . . . . . . . . . . . . 26
Password Protection
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Forcing Values and Configuring Items
. . . . . . . . . . 28
Page
CONFIGURATION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 28-42
Points Display Screen
. . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Thermostat Control Input Screen
. . . . . . . . . . . . . . . . 30
Alarm Service Configuration Screen
. . . . . . . . . . . . 30
Controller Identification Screen
. . . . . . . . . . . . . . . . . 31
Holiday Configuration Screen
. . . . . . . . . . . . . . . . . . . 31
Occupancy Configuration Screen
. . . . . . . . . . . . . . . 32
Set Point Screen
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Service Configuration Selection Screen
. . . . . . . . . 33
PremierLink Configuration Screen
. . . . . . . . . . . . . . 37
Occupancy Maintenance Screen
. . . . . . . . . . . . . . . . 39
Maintenance Screen
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
SAFETY CONSIDERATIONS
GENERAL
The PremierLink Controller is a field retrofit split system
control compatible with the Carrier Comfort Network (CCN).
This control is designed to allow users the access and ability to
change factory-defined settings thus expanding the function of
the standard unit control board. The complete PremierLink
package (part number 33CSPREMLK) consists of a control
circuit board with plastic cover and label, wire harnesses, spade
connectors, wire nuts and 4 mounting screws.
SAFETY NOTE
Air-handling equipment will provide safe and reliable service
when operated within design specifications. The equipment
should be operated and serviced only by authorized person-
nel who have a thorough knowledge of system operation,
safety devices and emergency procedures.
Good judgement should be used in applying any manufac-
turer’s instructions to avoid injury to personnel or damage to
equipment and property.
Disconnect all power to the unit before performing mainte-
nance or service. Unit may automatically start if power is
not disconnected. Electrical shock and personal injury
could result.
Damage to equipment may result. An individual field-
supplied 24-vac power transformer is required for each
PremierLink controller. The transformer must be less than
100 va to meet UL (Underwriters’ Laboratories) Class 2.
PremierLink™
Retrofit Split System
Controller

Summary

Safety Considerations

Safety Note

Provides guidance for safe operation of air-handling equipment and general safety advice.

Installation

Space Temperature Sensor (SPT)

Details the types and wiring of field-supplied space temperature sensors.

Supply Air Temperature Sensor (SAT)

Explains the SAT sensor requirements and its electrical specifications.

Indoor Air Quality CO2 Sensor

Describes the indoor CO2 sensors available for monitoring air quality.

Outdoor Air Quality CO2 Sensor

Details the outdoor CO2 sensor used for monitoring air quality in HVAC systems.

Outdoor Air Temperature Sensor

Outdoor Air Enthalpy Switch

Return Air Enthalpy Sensor

Mount PremierLink Control

Guidance on selecting a suitable location and physically mounting the PremierLink controller.

Connect to CCN Communication Bus

Instructions for connecting the PremierLink controller to the CCN communication bus.

Communication Bus Wire Specifications

Enthalpy and Differential Enthalpy Control

Enthalpy Switch;Receiver

Describes the accessory enthalpy switch/receiver for free cooling indication.

Enthalpy Switch;Receiver Mounting

Enthalpy Switch;Receiver Wiring

Enthalpy Sensor Mounting

Enthalpy Sensor Wiring

Enthalpy Switch;Receiver Jumper Settings

Enthalpy Sensor Jumper Settings

Economizer

Honeywell Actuator Interface

Information on interfacing with Honeywell actuators using adapter accessories.

Q769 B Adapter Installation

Q769 C Adapter Installation

Q769 B Wiring to Actuator

Q769 C Wiring to Actuator

Economizer with Johnson 4 to 20 mA Actuator

Drive Direction

Explains how to set the actuator drive direction based on switch settings.

Switch Selection

Details how to select the input control signal type (VDC or mA).

Wiring

Start-Up Procedures

Perform System Check-Out

Verifies connections, fan operation, electrical systems, and filters before initial operation.

Initial Operation and Test

Procedure for applying power and testing the controller with the Service Tool.

Install Navigator Display Module

Instructions for installing the Navigator display module for configuration and diagnostics.

Navigator Installation

Navigator Operation

Navigating Menu Structures

Configuration Options

Password Protection

Explains the password entry process for protected areas and items.

Forcing Values and Configuring Items

Describes how to force items and make user-configurable changes.

Points Display Screen

Monitors and changes PremierLink controller set points for various parameters.

Thermostat Control Input Screen

Alarm Service Configuration Screen

Controller Identification Screen

Holiday Configuration Screen

Occupancy Configuration Screen

Set Point Screen

Service Configuration Selection Screen

Staged Cooling

Staged Heating

IAQ PID Configuration

Submaster Center Value

Damper Movement Band

OAT Temp Band

Minimum Damper Position

Low Temp Minimum Damper Position Override

DX Cooling Lockout

Time Guard Override

Continuous Power Exhaust

Supply Fan Status Enable

Maximum Offset Adjustment

Space Temperature Trim

Supply Air Temperature Trim

PremierLink Configuration Settings

Configures various operating modes, heat types, unit types, and communication settings.

Occupancy Maintenance Screen

Checks the occupied schedule and displays current occupancy status and timing.

Carrier PREMIERLINK 33CSPREMLK Specifications

General

Brand	Carrier
Model	PREMIERLINK 33CSPREMLK
Category	Controller
Language	English