SERVICE INFORMATION
V. Radiator
a. Refill the radiator with distilled water or specified
additives.
b. Add coolant to the reservoir.
c. The cooling system can be serviced on the buggy.
d. Never spill the coolant on the painted surface.
e. Test the cooling system for any leakage after the
repair.
W. Storage Instructions
In the event that your buggy is not to be operated for a period exceeding 30 days or at the end
of each driving season, prepare for storage as follows:
a. Drain fuel tank and carburetor by allowing
engine to run out of fuel and use a fuel stabilizer.
b. Lubricate engine cylinder by removing the air
cleaner, then spray engine, fogging oil through the
carburetor until motor dies.
c. Do not save or store gasoline over winter. Using
old gasoline, which deteriorates from storage,
will cause hard starting and affect engine performance.
Do not drain fuel while engine is hot. Be sure to move kart outside before draining fuel.
While engine is running, never attempt to open the radiator filler cap. The pressurized
hot coolant may shoot out and cause serious scalding injury. No maintenance work is
allowed to be performed unless the engine is completely cooled down.
WARNING
38
WARNING
To Next Page
Loading...
