27
PROPANE SYSTEM
Please observe the warnings and cautions contained in
this section as well as the manufacturers supplied
information with each gas appliance. Propane is stored in
a high-pressure tank in liquid form and is delivered to the
appliances in a gaseous form. The propane container(s)
must not be placed or stored inside a vehicle. The
container(s) are equipped with safety devices that relieve
excess pressure by discharging propane to the
atmosphere.
BTU’S
One gallon of propane produces approximately 91,502
BTU’s. Using the BTU rating of each gas appliance in
your RV, you can determine about how long your supply
will last according to your usage. Dual 5 gallon propane
bottles hold approximately 862,026 BTU’s
SAFETY PRECAUTIONS
Propane is of course highly flammable and also heavier
than air. It’s treated to have a garlic like odor to detect a
leak. If a leak should occur, the propane can collect in
pockets along the floor and thereby dissipate the air. If
unnoticed, this could result in suffocation or an
explosion.
USING PROPANE SYSTEM
It is normal to have a slight gas odor when initially
opening the outlet valve. Fully open and seat valve by
hand only to prevent leakage past the valve stem. If an
odor seems to linger perform a leak test. Keep outlet
valves closed when not using the propane system. Do not
attempt to adjust the regulator. The manufacturer has
preset it. If any adjustment is required, a qualified
propane service technician using special equipment must
make it.
PROPANE TANKS are equipped with a two-stage
automatic changeover regulator, which transfers
propane demand automatically to the second tank when
the first tank becomes empty. For proper operation, both
outlet valves must be opened. Turn or slide the tank
selector knob so it points to the tank you wish to provide
service. A small glass window is located on the
regulator. A clear or green band will appear in the
window indicating that pressure is in the line from the
tank. After all propane is used from that tank, the
regulator will automatically switch service to the other
tank, and a red band will show in the window, with the
arrow or slide pointing to the empty tank. The empty
tank can be removed for filling without disturbing the
gas flow to the camper by rotating or sliding the tank
selector to the full tank. The red band will disappear
from the window indicating Pressure supply from the
full tank.
DANGER
IF YOU SMELL PROPANE
1. Extinguish any open flames, pilot lights and all
smoking materials. Do not touch electrical switches. Shut
off the propane supply at the tank valve(s) or propane
supply connection. Open door and other ventilating
openings. Leave the area until odor clears. Have the
propane system checked and leakage source corrected
before using again.
2. Inspect the entire propane system for leaks or damaged
parts before each trip.
3. Never check for leaks with an open flame. Use an
approved leak detection solution or a non-ammoniated,
non-chlorinated soap solution only. If the leak cannot be
located, have the system checked by qualified personnel.
4. Always be careful when drilling holes or fastening
objects to the camper. A nail or screw could puncture the
propane supply lines.
5. Do not restrict access to propane tanks. In an
emergency, the tank service valve must be easily
accessible. Do not store items or block ventilation
openings in the propane compartment.
6. Do not use any propane tanks other than those
furnished with your camper. Turn off main propane valve
and individually turn off all propane appliances or
electrically disconnect automatic ignition appliances
before entering propane bulk plant or motor fuel service
station. When not individually turned off, automatic
ignition appliances may continue to spark. Do not fill
propane containers to more than 80% capacity.
Overfilling can result in uncontrolled propane flow that
can cause fire and explosion. A properly filled
container holds about 80% of its volume as liquid.
7. Propane regulators must always be installed with the
diaphragm vent facing downward within 45° of vertical
to minimize vent blockage that could result in excessive
propane pressure causing fire or explosion.
8. Do not use a wrench or pliers to close the service valve.
This valve is designed to be closed leak tight by hand. If
a tool is required to stop a leak, the valve probably needs
repair or replacement.
9. When attaching the hose connector to the valve, don’t
force, jam or cross-thread the fitting. Always check
fitting for leaks after tightening.
10. Be sure the tanks are securely fastened whenever they
are mounted on the camper.
11. Go to a Chalet dealer for any propane system repairs.
12. Always think safety.
To Next Page
Loading...