Char-Broil 12701705 - User Manual

Other manuals for Char-Broil 12701705

Product Guide44 pages

Questions and Answers

A
Ashley SaundersAug 17, 2025
What to do if my Char-Broil 12701705 Smokers burner won't light?
- T
  Terrance SandersAug 17, 2025
  If the burner on your Char-Broil Smoker won't light using the ignitor, make sure the LP cylinder isn't empty. If it isn't, the issue might be a sudden drop in gas flow. Also, ensure the coupling nut and LP cylinder valve are fully connected. If not, turn off the knobs, disconnect the coupling nut, reconnect it, and try again. You may also try tightening the coupling nut approximately one-half to three-quarters additional turn until solid stop. Remember to tighten by hand only, without using tools.
K
kayla26Aug 19, 2025
Why won't the ignitor light on my Char-Broil Smoker?
- M
  Matthew JonesAug 19, 2025
  If the burner on your Char-Broil Smoker won't light using the ignitor, the electrode tip might not be in the proper position. The tip of the electrode should point toward the gas port opening on the burner, with a distance of 1/8” to 1/4”. Adjust if necessary. Also, the distance may be 1/8” to 3/16”.
E
Erin JohnsonAug 22, 2025
How to fix ignitor on Char-Broil 12701705?
- K
  Kelly HollandAug 22, 2025
  If the burner on your Char-Broil Smoker won't light using the ignitor, the wires may be loose or disconnected. Reconnect the wires or replace the electrode/wire assembly. Also, cooking residue may have accumulated on the wire and/or electrode. Clean the wire and/or electrode with rubbing alcohol and a clean swab.
N
Natalie SandersAug 26, 2025
What causes Char-Broil 12701705 Smokers igniter not to work?
- A
  Andrea WilliamsAug 26, 2025
  If the burner on your Char-Broil Smoker won't light using the ignitor, the electrode might be cracked or broken, causing sparks at the crack. If this is the case, replace the electrode(s).
S
Steve SmithAug 28, 2025
Why is my Char-Broil Smoker flaring up?
- W
  wandathompsonAug 28, 2025
  Flare-ups in Char-Broil Smokers often result from grease buildup. To resolve this, clean the burner and the inside of the fryer body. Also, excessive fat in the meat can cause flare-ups; trim the fat before grilling. Finally, adjust the temperature, lowering it if it's too high.
S
Shane PerezAug 30, 2025
What to do if Char-Broil Smoker has sudden drop in gas flow?
- D
  Diana JordanAug 30, 2025
  A sudden drop in gas flow or low flame in your Char-Broil Smoker can be due to several reasons. First, check if the LP cylinder is out of gas. If not, the excess flow valve may have tripped; turn off the knob, wait 30 seconds, and try lighting the fryer again. If the flames remain low, turn off both the knob and the LP cylinder valve, disconnect the regulator, reconnect it, perform a leak test, turn on the LP cylinder valve, wait 30 seconds, and then light the fryer. A vapor lock at the coupling nut/LP cylinder connection could also be the cause; turn off the knob and LP cylinder valve, disconnect the coupling nut from the cylinder, reconnect it, and try again.
M
Melissa KaufmanSep 2, 2025
Why do the flames blow out on my Char-Broil Smoker?
- J
  Julian RobertsonSep 2, 2025
  If the flames on your Char-Broil Smoker are blowing out, it could be due to a couple of reasons. You might be low on LP gas, so try refilling the LP cylinder. Alternatively, the excess flow valve may have tripped; in this case, refer to the instructions for a sudden drop in gas flow.
J
jennifer72Sep 5, 2025
What to do if Char-Broil Smoker has persistent grease fire?
- T
  Thomas SavageSep 5, 2025
  If you're experiencing a persistent grease fire in your Char-Broil Smoker, it's likely due to grease trapped by food buildup around the burner system. To address this, turn the knob to OFF, turn off the gas at the LP cylinder, and let the fire burn out. Once the fryer has cooled down, remove and clean all the parts.
M
Michael MoralesSep 7, 2025
What causes flashback fire in burner tube of Char-Broil Smoker?
- S
  Sherry JonesSep 7, 2025
  If you're experiencing a flashback (fire in the burner tube) with your Char-Broil Smoker, it indicates that the burner and/or burner tube is blocked. To resolve this, turn the knob to OFF and clean the burner and/or burner tube. Consult the burner cleaning section of the Use and Care guide for detailed instructions.
H
Heather OrtizSep 12, 2025
Why is my Char-Broil Smoker cooking slower than expected?
- R
  ravengoodSep 12, 2025
  If your Char-Broil Smoker is cooking slower than expected, high wind conditions could be the cause; relocate the cooker to a less windy area. Also, vapor lock can cause that; turn off the knob and disconnect the coupling nut from the LP cylinder, then reconnect and retry. Finally, the valve may not be properly aligned to the burner; loosen the control panel and valve, ensure the valve is centered top to bottom and left to right in the burner tube, and then tighten all components once proper alignment is achieved.

Summary

Outdoor Use Directive

Installation and Safety Guidance

Understanding Safety Symbols

Use and Care Fundamentals

LP Cylinder Specifications

Details required specifications for the LP cylinder used with the grill.

LP Cylinder Handling and Storage

Provides instructions for safe removal, transport, and storage of LP cylinders.

LP Gas Properties and Filling

Explains LP gas characteristics and procedures for safe cylinder filling.

LP Cylinder Services and Connections

LP Cylinder Exchange and Leak Testing

Guides on exchanging cylinders and performing leak tests for safety.

Regulator Connection Procedure

Step-by-step instructions for connecting the regulator to the LP cylinder.

Regulator and Hose Leak Testing

Leak Testing Valves, Hose, and Regulator

Procedure for testing the gas system for leaks before operation.

Appliance Operation and Maintenance

Ignition and Burner Operation

Instructions for lighting the burner using ignitor or match, and checking flame.

System Checks and Shutdown

Procedures for checking ignitor, valve, hose, and turning off the appliance.

General Appliance Cleaning

Guidelines for cleaning plastic, painted, and stainless steel surfaces.

Burner Assembly Cleaning

Cleaning Burner Tube and Venturi

Detailed steps for cleaning the burner tube and venturi for optimal performance.

Burner Assembly Reassembly Steps

Instructions for reassembling the burner and control panel assembly correctly.

Spider Alert and Prevention

Food Safety Practices

Four Basic Food Safety Steps

Covers cleaning, separating, cooking, and chilling for safe food preparation.

Internal Cooking Temperature Guidelines

Provides USDA recommended minimum internal temperatures for various meats.

Storage and Safety Precautions

Appliance Storage Guidelines

Instructions for storing the appliance indoors or outdoors safely.

Cooking Safety Precautions

Key safety tips to follow while cooking, including surface heat and ventilation.

Cooking Setup and Techniques

Using Wood Chips and Chunks

Instructions for preparing and using wood chips or chunks for smoking.

Water Pan Setup and Flavor Options

Guidance on filling the water pan and adding flavor enhancers.

Cooking Grates and Placement

Instructions for placing cooking grates and arranging food for optimal cooking.

Smoking Performance Factors

Discusses how ambient temperature and wind affect smoker performance.

Parts Diagram and Hardware List

Assembly Instructions - Step 1 & 2

Step 1: Door Removal and Smoker Chamber Placement

Instructions for removing the door and positioning the smoker chamber.

Step 2: Install Burner Housing

Attaching the burner housing to the smoker chamber with bolts.

Assembly Instructions - Step 3 & 4

Step 3: Attach Control Panel Assembly

Connecting the control panel assembly to the smoker chamber and burner housing.

Step 4: Install Ignitor Wire

Routing and connecting the electrode wire to the rotary ignitor.

Assembly Instructions - Step 5 & 6

Step 5: Install Legs

Attaching the legs to the smoker body using bolts and nuts.

Step 6: Stand Unit Upright

Safely raising the assembled unit onto its legs with assistance.

Assembly Instructions - Step 7 & 8

Step 7: Install Damper and Side Handles

Installing the top damper assembly and side handles for the unit.

Step 8: Install Drawer and Water Pan

Placing the water pan into the smoker drawer and sliding it into the unit.

Assembly Instructions - Step 9 & 10

Step 9: Insert Cooking Grates

Inserting the cooking grates and top grate into their designated positions.

Step 10: Install Thermometer

Attaching the thermometer to the smoker door.

Troubleshooting Emergencies

Gas Leaks and Fire Incidents

Addresses issues like gas leaks from hoses, cylinders, or fires.

Burner Ignition Problems

Diagnoses and solutions for burner not lighting with ignitor.

Advanced Troubleshooting

Burner and Gas Flow Issues

Troubleshoots burner not lighting, low flame, blowouts, and flare-ups.

Grease Fires and Flashbacks

Solutions for persistent grease fires and flashbacks in the burner tube.

LP Cylinder and Cooking Performance

Addresses issues with filling LP cylinders and slow cooking performance.

Limited Warranty Information

Product Registration

Char-Broil 12701705 Specifications

General

Type	Electric Smoker
Fuel Type	Electric
Temperature Control	Digital
Built-in Thermometer	Yes
Wheels	Yes
Number of Racks	4
Power Source	Electric
Construction Material	Steel
Digital Control	Yes
Built-in Meat Probe	Yes