CITROEN DS 19 - Page 194

DS 19 OPERATION No. DS 330-1 : Work on the gearbox. Op. DS 330-1 192
TOOLS
55 Fit the connecting pipe between the pump and the pressure regulator (spanner 2220-T and 2280-T, see Pl. 72,
fig. 4 and 5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Spanner 2220-T and
Spanner 2280-T
56 Fit the brake connecting cable and adjust (see Op. DS 454-0).
Fit the thrust block bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 mm spanner
12-14 mm box spanners
57 Fit the steering (see Op. DS 100-1, paragraphs 43 to 45). Note the markings made when dismantling.
Fit the front crossmember. Connect the steering levers to the relay shafts. Position and tighten the screws.
Fixing the gearbox support arms to the crossmember. Remove the stand 1797-T or disengage the wooden wedge. 14-16 mm box
spanners
58 Fit the radiator. Fix the pressure regulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-14mm box spanners
59 Fit the battery bracket and the battery. Fix the earth lead . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 mm spanner
8-14mm box spanners
60 Refill the radiator. Start the engine, bleed the water system.
Put the systems under pressure. Make successive movement through all the gears. Check the unions for
leakage. Stop the engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 mm spanner
61 Fit the air deflection panel. Fit the wings and spare wheel support. Fit the spare wheel . . . . . . . . . . . . . . . . . . . . 14 mm spanner
12-14 mm box spanners