COMINOX STERILCLAVE 18 B - User Manual

SERVICE MANUAL
-Steam Steriliser-
FOREWORD
This manual IS NOT an integral part of the steriliser.
The manual is addressed to qualified, specialised technicians for routine maintenance
and repairs.
Technicians or operators mused be authorised in writing by COMINOX.
Technicians must read this manual and follow the instructions herein contained. COMINOX
is not liable for any injury and/or damage to people or property or to the steriliser itself
should the conditions herein illustrated be disregarded.
This manual contains industrial secrets which must not be disclosed. The manual and its
annexes must not be edited, modified, copied or given to third parties unless authorised
by COMINOX.

Summary

TECHNICIAN MENU

Input and Output Status Display

Shows status of steriliser inputs and outputs, aiding diagnostics.

Calibration and Correction Procedures

Guides for calibrating temperature probes and pressure transducer, and correcting readings.

ALARMS

Water Quality and Level Alarms

Alerts for poor water quality or insufficient water levels in the tank.

Chamber, Steam, and Vacuum Alarms

Alarms related to chamber filling, steam leakage, and vacuum generation issues.

Temperature and Pressure Related Alarms

Alarms for pressure, temperature deviations, and calibration errors.

Probe, Coil, Door, and System Alarms

Alarms for probe issues, coil faults, door closure faults, and other system malfunctions.

AUTOMATIC WATER INLET AND DIRECT DRAIN INSTALLATION

System Installation and Setup

SPEEDY WATER Demineralization System Installation

System Connection and Maintenance

SterilCard Reader Installation

Reader Kit Assembly and Mounting

Printer Installation Procedure

Printer Mounting and Connection Steps

Firmware Upgrade Process

Software and Firmware Update Procedure

Detailed steps for upgrading steriliser firmware, configuration, and parameters.

DIAGRAMS AND WIRINGS

Logic and Power Board Schematics

Diagrams and component identification for logic and power boards.

Model-Specific Wiring Diagrams

Electrical wiring schematics for 18/24 S, 6 S Dynamica, and 18 S Dynamica models.

Model-Specific Hydraulic Diagrams

Cycle Phase Diagrams

CYCLE SET POINTS

18;24 B- BHD and 18 S Cycle Parameters

COMINOX STERILCLAVE 18 B Specifications

General

Category	Laboratory Equipment
Chamber Volume	18 liters
Type	Autoclave
Water Filling	Automatic
Safety Features	Door lock, over-temperature protection, over-pressure protection
Power Supply	230V / 50-60Hz
Material	Stainless Steel