Continental Fireplaces CBI 360-N User Manual

1
W415-0120 / F / 10.25.11
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
INSTALLATION AND
OPERATING INSTRUCTIONS
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)722-6031 • www.continentalfi replaces.com • ask@continentalfi re.on.ca
1.31A
$10.00
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
SAFETY INFORMATION
!
WARNING
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by a
qualifi ed installer, service agency or the supplier.
If the information in these instructions
are not followed exactly, a fi re or
explosion may result causing property
damage, personal injury or loss of life.
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
WARNING
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certifi ed kit is used.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CSA 2.22, ANSI Z21.50 FOR VENTED GAS FIREPLACES.
CBI 360 - N
NATURAL GAS
CBI 360 -P
PROPANE

Continental Fireplaces CBI 360-N Specifications

General

Model	CBI 360-N
Category	Indoor Fireplace
Fuel Type	Natural Gas
Ignition System	Electronic Ignition
Vent Type	Direct Vent
Finish	Black

Summary

SAFETY INFORMATION

PRESIDENT'S LIFETIME LIMITED WARRANTY

CONDITIONS AND LIMITATIONS

GENERAL INSTALLATION INSTRUCTIONS

GENERAL INFORMATION

CARE OF GLASS AND PLATED PARTS

INSTALLATION PROCEDURES

FINISHING TOUCHES

FIBRE FIREBRICK PANELS

Optional panels for an authentic masonry fireplace look.

LOG PLACEMENT GUIDE

Instructions for positioning logs for optimal glowing effect and flame.

CHARCOAL EMBERS INSTALLATION

Placement of embers for realistic glowing effects and proper function.

LOUVRE KIT INSTALLATION

Steps to install upper and lower louvres for a finished appearance.

OPERATION AND MAINTENANCE

SPILL SWITCH SAFETY FEATURE

Safety switch that shuts off gas in case of vent blockage or downdraft.

VENTING ACTION CHECK PROCEDURE

Test to ensure proper and safe venting of the fireplace.

PRE-LIGHTING SAFETY AND OPERATION

SAFETY BEFORE LIGHTING

Crucial safety checks and procedures before attempting to light the fireplace.

GAS LEAK RESPONSE

Actions to take immediately if a gas leak is detected.

LIGHTING INSTRUCTIONS

Step-by-step guide for safely lighting the pilot and main burner.

ROUTINE MAINTENANCE

Procedures for cleaning and inspecting the fireplace for optimal performance.

BLOWER SYSTEM AND ADJUSTMENTS

BLOWER REPLACEMENT

Instructions for safely removing and replacing the fireplace blower unit.

ADJUSTING PILOT BURNER

How to adjust the pilot flame size for correct operation.

VENTURI AIR SHUTTER ADJUSTMENT

Guidelines for adjusting air shutters for optimal flame color and combustion.

REPLACEMENT PARTS AND ACCESSORIES

ORDERING REPLACEMENT PARTS

Information required when ordering parts, including model and serial numbers.

AVAILABLE ACCESSORIES

List of optional accessories to enhance the fireplace appearance and functionality.

TROUBLESHOOTING COMMON ISSUES

APPLIANCE SERVICE HISTORY LOG

NOTES AND REMINDERS