raise the rear of the kart so that both tires remain off the ground. Be
sure to use jack stands to hold the kart in place. Using O-Ring safe
chain lubrication, spray the chain while hand-rotating the tires.
Never attempt to get under a raised kart.
Adjusting The Shocks
The front and rear shocks each have five adjustable positions. The
default position has been set by the manufacturer and is located in
the middle. The tension of the shock will change depending on the
way that it is rotated. To increase the tension, rotate to the right, to
decrease the tension, rotate to the left. It is important to adjust the
shocks to correspond to the weight of the riders. Do NOT attempt to
operate this kart if the shocks in the front are not on the same
settings, or if the shocks in the back are not on the same settings.
Storing
These steps should be followed if your vehicle is not going to be
operated for a period of thirty (30) days or more.
1. Drain the fuel tank. Remove all fuel in the tank using an
approved suction device. Allow the engine to run out of fuel.
Allowing the engine to run out of fuel will clear the remaining
fuel from the carburetor.
WARNING: Do NOT handle gas near an open flame
or while smoking.
WARNING: The pipe, muffler, and heat shields are
extremely hot during and after operation. Do NOT touch them until
they have cooled. The engine exhaust from this product contains
chemicals known to cause cancer, birth defects, and other
reproductive harm. Gasoline powered engine exhaust fumes are
poisonous and may cause loss of consciousness, and/or death. Avoid
prolonged exposure.
IMPORTANT INFORMATION
Engine Identification and VIN Number
1. The engine identification number is located on the driver’s side of
the go-kart, directly behind the muffler.
2. The number is on a decal on the engine casing directly below the
bar code.
3. The VIN number is stamped into a plate on the frame, next to the
top of the rear shock on the driver’s side.
3. Please have these numbers handy when ordering new parts or
contacting customer service.
Gas
1. This go-kart operates on unleaded fuel, rated 93 octane.
WARNING: Use caution when handling gasoline to avoid
injury.
- Always refuel outside in a well ventilated area with the engine
turned off. Allow the engine to cool before adding fuel.
- Do NOT spill any fuel while fueling and be sure to tighten gas
cap when fueling is complete. Do NOT smoke or expose flames
to gasoline. If fuel comes into contact with the skin, rinse area
immediately.
Oils
Engine Oil
1. This engine operates on SF-SG (SAE 10W-40) motor oil.
2. Please refer to the section on changing the engine oil for proper
instructions on how to change the engine oil.
Final Gear Oil
1. The gears for this go-kart require GL-5, GL-4, GL-3
(SAE 80W-90) gear oil.
Engine ID Number:
________________
VIN Number:
________________
41 42
To Next Page
Loading...