SMART CARD MODULE LEGEND:
HYBRID CONTROL POWER MODULE LEGEND:
4
3
2
1
6
12
9
13
11
10
12
11
10
9
8
4
14
8
7
1
2
1
3
7
6
3
2
5
4
C NO
4
3
2
1
120V, 60W
120V, 60W
WHIPPER MOTOR #4
120V, 60W
WHIPPER MOTOR #3
120V, 60W
WHIPPER MOTOR #2
WHIPPER MOTOR #1
(WHT)
RED (DATA_COMM FIRST)
WHT or VIO (Vss- LOGIC COMMON)
BLK (Vdd+ 5Vdc)
GRN
STP RED
RED
RED
WHT
WHT
WHT
STP VIO
STP BLU
STP BRN
(FOR CAFEPC4)
STP RED
VIO
GRN
BLU
WHT
VIO
WHT
WHT
WHT
BLU
WHT
WHT
WHT
BLK
WHT
(WHT)
12VAC
120VAC
RED/14GA
STP YEL
STP YEL
ORG
STP GRN
STP GRY
BRN
YEL
BLK
WHT
BLK
BLK
BLK/14GA
BLK
BRN
WHT
WHT
WHT
WHT/14GA
BLK/14GA
(BLK)
(BLK)
WHT/14GA
(BLK)
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
GRN
RED/14GA
BLK/14GA
ORG (DATA_COMM NEXT)
YEL (Vdd+ 5VDC)
VIO (Vss- LOGIC COMMON)
(WHT)
(BLK)
12VAC
(BLK)
(VIO or BLU)
120VAC
(RED)
(FOR CAFEPC3)
STP VIO
STP BLU
(FOR CAFEPC2)
(FOR CAFEPC1)
STP BRN
ALTERNATE
TRANSFORMER
WIRE HOOKUPS
2
3
5 8
WHT or RED
AND/OR DIFFERENT ENDING NUMBERS ON THEIR PART NUMBERS AND
2 USE THIS DIAGRAM FOR ALL OTHER MODELS WITH ADDED PREFIX
1 WIRE GROUND LUG TO TANK STUD BEFORE INSTALLING ON CHASSIS.
Ex.: (SC)CAFEPCxCS10000 and/or (SC)CAFEPCxCS20000
DO NOT INSTALL ON TANK LID SCREWS.
WITH EQUIVALENT ELECTRICAL RATINGS.
NOTES: UNLESS OTHERWISE SPECIFIED
CHASSIS GROUND
1
CHASSIS GROUND
1
120V, 66W
DUMP VALVE #4
GEAR MOTOR #4
G4
120V, 66W
120V, 12W
W4
2.5W, 120V
HYBRID MICRO CONTROLLER
DUMP VALVE #3
GEAR MOTOR #3
G3
W3
120V, 12W
G2
120V, 66W
GEAR MOTOR #2
DUMP VALVE #2
GEAR MOTOR #1
W2
120V, 12W
120V, 66W
G1
240/120VAC-12VAC
RESET
SPST
SET AT 220°F
THERMOSTAT
TOGGLE SWITCH
SPST 25A 125/250V
WATER LEVEL
PROBE ASSY
TANK
WATER
T°
SENSOR
TEMP.
12VAC
120/240VAC
2
12-PIN CONNECTOR
14-PIN CONNECTOR
TRANSFORMER
DUMP VALVE #1
1 GPM, 120V, 10W
INLET VALVE
W1
120V, 12W
HEATER ELEMENT(SEE TABLE)
120V
A
B
30W LIGHT ASSY
BALLAST
120VAC
POWER SUPPLY
120V, 60Hz 15W
EXTRACTOR FAN
.47MF CAPACITOR
275VAC
L1
2
1
BLK
BLK
N
OPTIONAL
S
WHT
G
HYBRID CONTROL POWER MODULE
COM
CONNECTOR
14 PIN
12 PIN
CONNECTOR
NO
ELECTRICAL RATING TABLE
US MODELS
(SC)CAFEPCxCS10000
(SC)CAFEPCxCS20000
1800
MACHINE
TOTAL
POWER
(WATTS)
1600
1150
15
1350 12
HEATING
(WATTS)
ELEMENT
CANADIAN MODELS
POWER
(WATTS)
CURRENT
TOTAL
(AMP.)
TOTAL
CURRENT
(AMP.)
TOTAL
4-PIN CONNECTOR
SMART CARD MODULE #1
SMART CARD MODULE #2
4-PIN CONNECTOR
COMMUNICATION CABLE
3-WIRE SHIELDED
CHASSIS GROUND
RIGHT
LEFT
12VAC
120/240VAC
(USED ON CAFEPC4)
1). CAFEPC1 USES VALVE #1 & MOTORS #1
2). CAFEPC2 USES VALVES #1,#2 & MOTORS #1,#2
3). CAFEPC3 USES VALVES #1,#2,#3 & MOTORS #1,#2,#3
4). CAFEPC4 USES VALVES #1,#2,#3,#4 & MOTORS #1,#2,#3,#4
S-5= STOP/WASH STATION
S-1= STATION #1
S-3= STATION #3
S-2= STATION #2
S-1
S-2
S-3
S-5
S-5= STOP/WASH STATION
S-4= STATION #4
S-3= STATION #3
S-2= STATION #2
S-1= STATION #1
S-1 S-2
S-4S-3
S-5
MODULE #1MODULE #2
S-5
S-1
S-5= STOP/WASH STATION
S-3= STATION #2
S-1= STATION #1
S-1
S-3
S-5
S-5= STOP/WASH STATION
S-1= STATION #1
CAFEPC1 CAFEPC2
CAFEPC3 CAFEPC4
PHASE:
WIRES:
AMPERAGE:
WATTAGE:
HERTZ:
VOLTAGE:
REVISION:
PART NUMBER:
TITLE:
1-PH
2W+G
SEE TABLE
60Hz
SEE TABLE
120VAC
-
LADDER DIAGRAM
SMART CARD VERSION
LD-CAFEPCx(SCV)-10
To Next Page
Loading...
