MAINTENANCE
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
5 - 18
5
Over the life of the battery, a considerable amount of water is consumed. It is important that the water used be pure
and free of contaminants that could reduce the life of the battery by reducing the chemical reaction. The water must
be distilled or purified by an efficient filtration system. Water that is not distilled should be analyzed and, if required,
filtration installed to permit the water to meet the requirements of the water purity table.
Even if the water is colorless, odorless, tasteless and fit for drinking, the water should be analyzed to see that it does
not exceed the impurity levels specified in the table.
Automatic watering devices such as the one included in the Battery Maintenance Kit (P/N 25587-G01) can be used
with an approved water source. These watering devices are accurate, easy to use and allow for rapid filling. They
also maintain the correct electrolyte level within the battery cells.
The watering device should only be used if the electrolyte level is less than 1/2” (13 mm) above top of plates.
The electrolyte in a storage battery is an acid solution which can cause severe burns to the skin
and eyes. Treat all electrolyte spills to the body and eyes with extended flushing with clear water.
NOTICE
WATERING GUN SIMILAR TO THE TYPE INCLUDED
IN THE E-Z-GO BATTERY MAINTENANCE KIT
PURE WATER
VALVE
CONSISTENTLY
FILLS TO A
PREDETERMINED
LEVEL
ELECTROLYTE
LEVEL
SINGLE BATTERY CELL
Automatic Watering Gun
To Next Page
Loading...
