Daewoo Forkilt - Page 141

Maintenance Section
-139-
Inspect Coolant Hoses (LP Engine Only).......... 183
LP Regulator/Converter Inspection (LP Engine
Only) .................................................................. 183
Fuel Lines & Fittings - Check............................. 184
Inspect Mixer Assembly (G424E/G430E Engine
Only) .................................................................. 184
Inspect Throttle Assembly (G424E/G430E Engine
Only) .................................................................. 184
Fuel Filter (DB33A Diesel Engine Only) - Change
........................................................................... 184
Every 1500 Service Hours or 9 Months
Inspect Ignition System (LP-Gas, Gasoline & Dual
Fuel Engines Only) ............................................ 185
Replace Spark Plugs (LP-Gas, Gasoline & Dual
Fuel Engines Only) ............................................ 185
Replace LP Fuel Filter Element (LP-Gas, Dual Fuel
Engine Only)...................................................... 186
Fuel Filter(LP-Gas Engine Only) ....................... 187
Testing Fuel Lock-off Operation (LP-Gas Engine
Only) .................................................................. 187
Every 2000 Service Hours or Yearly
Fuel Filter(G424 Gasoline & Dual Fuel Engine
Only) - Change .................................................. 188
Engine Valve Lash (B3.3 Diesel Engine Only) –
Check, Adjust..................................................... 188
Steer Wheel Bearings - Reassemble................. 189
Drive Wheel Bearing (Power Shaft and Drive
Wheel) – Reassemble ....................................... 191
Cooling System - Clean, Change ...................... 192
Forks – Inspect .................................................. 193
Every 2500 Service Hours or 15 Months
Hydraulic Oil - Check, Clean, Change............... 195
Inspect Battery System...................................... 195
Checking the TMAP Sensor (G424E/G430E Engine
Only) .................................................................. 196
Inspect for Intake Leaks (G424E/G430E Engine
Only) .................................................................. 197
Replace PCV Valve and breather element - Change
(LP-Gas, Gasoline and Dual Fuel Engines) ...... 197
Every 3000 Service Hours or 18 Months
Timing Belt [G424(E) LP-Gas, Gasoline Dual Fuel
Engine Only] - Change ....................................198
Timing Belt for Counterbalance Shaft [G424(E)
LP-Gas, Gasoline & Dual Fuel Engine Only]
- Change.............................................................198
Every 4500 Service Hours or two Years
Replace Oxygen Sensor (G424E/G430E Engine
Only)...................................................................199