Operation Section
-96-
Problem Probable Cause Corrective Action
Incorrect Idle speed control
Incorrect timing or spark control
See Advanced Diagnostics & See
G424E/G430E Engine Service Manual
Rough Idle
Engine Mechanical See Engine Service Manual
Incorrect Idle speed control
Throttle sticking
See Advanced Diagnostics & See
G424E/G430E Engine Service Manual
High Idle Speed
Foot pedal sticking or incorrect
pedal signal
Check pedal return spring travel for binding
z See Advanced Diagnostics
Clogged fuel filter Repair/replace as required
z See Maintenance section, Fuel
Filter replacement
Plugged fuel line Remove obstruction from the fuel line
z Close liquid fuel valve
z Using caution, disconnect the fuel
line (some propane may escape)
z Clear obstruction with compressed
air
z Re-connect fuel line
z Slowly open liquid fuel valve & Leak
test
Air filter clogged Check air filter
z Clean/replace as required
Faulty vapor connection between
the pressure regulator/converter
and the mixer
Check connection
z Verify no holes in hose
z Clamps must be tight
z Look for kinked, pinched and/or
collapsed hose
Pressure regulator malfunction Test pressure regulator operation
z See G424E/G430E Engine Service
Manual
Air/Fuel Mixer malfunction Check mixer
z See G424E/G430E Engine Service
Manual
Restricted exhaust system Check exhaust system
z Measure exhaust back pressure
Incorrect ignition control
Incorrect air/fuel control
Poor High Speed
Performance
Incorrect throttle position
See Advanced Diagnostics & See
G424E/G430E Engine Service Manual
To Next Page
Loading...
