Daikin MPS015 F - MPS 030-050 VAV Control with Variable Speed Inverter Compressor

132 pages

To Next Page

To Previous Page

Figure 67: MPS 030 – 050 VAV Control with Variable Speed Inverter Compressor

WIrInG dIaGrams

www.DaikinApplied.com 75 IM 1058-8 • MAVERICK II ROOFTOP SYSTEMS

Main Page

Default Chapter2
- Table of Contents2
General Information3
- Unit Nameplate3
- Hazard Identification Information3
Mechanical Installation4
- Installer Responsibilities4
- Receiving Inspection4
- Service Clearance4
- Ventilation Clearance5
- Overhead Clearance5
- Roof Curb Assembly and Installation5
- Assembly Instructions6
Mechanical Installation11
- Rigging and Handling13
- Condensate Drain Pipe Connection15
Mechanical Installation15
- Cabinet Weather Protection16
- Installing Ductwork16
Electrical Installation19
- Field Power Wiring19
Electrical Installation20
Preparing Unit for Operation21
- Spring Isolated Fans21
Optional Gas Heat22
- Daikin Applied Tubular Heater Series22
- Package Heater Module22
- Gas Furnace Design23
Optional Gas Heat23
- Installation25
Optional Gas Heat27
- Start-Up Procedures32
Optional Electric Heat38
- Electric Heater Design38
Optional Modulating Hot Gas Reheat39
- Modulating Hot Gas Reheat39
Optional Modulating Hot Gas Reheat40
Optional Hot Water Heat42
- Hot Water Heater Design42
Optional Energy Recovery Wheel45
- Energy Recovery Wheel Design45
Optional Outdoor Air Monitor48
- Thermal Dispersion Airflow Measurement Technology48
Unit Options53
- Economizer Enthalpy Contro53
- External Time Clock53
- Exhaust Fan Option53
- Proof-Of-Airflow and Dirty Filter Switch53
- Duct High Pressure Limit53
- Convenience Receptacle (Field Powered)54
- Convenience Receptacle (Unit Powered)54
- Condenser Fan Operation for Variable Speed Compressor55
- Low Ambient Option55
- VFD Compressor Operation56
- Variable Speed Scroll Compressor61
Wiring Diagrams64
Sequence of Operation90
- Operating States90
- Mechanical Cooling91
Check, Test, and Start Procedures92
- Pre-Start of Unit92
- Servicing Control Panel Components92
- Energy Recovery Wheel96
Final Control Settings97
- Controller Settings for Normal Operation97
Maintenance98
- Performing Service Maintenance98
- Control Panel Components102
- Unit Storage105
- Bearing Lubrication106
- Energy Recovery Wheel107
- Segment Installation & Replacement109
- Wheel Drive Motor & Pulley Replacement109
- Belt Replacement110
- Troubleshooting110
- Supply Fan111
- Refrigerant Charge111
- Servicing Optional Electric Heater111
Service and Warranty Procedure112
- Replacement Parts112
- Compressors112
- In-Warranty Return Material Procedure112
Warranty Registration Form113
Quality Assurance Survey Report119
Appendix - Keypad/Display Menu Structure120

Daikin MPS015 F - MPS 030-050 VAV Control with Variable Speed Inverter Compressor

Table of Contents

Related product manuals