Daikin Navigator WWV - Default Chapter; Table of Contents

NAVIGATOR WWV/TWVDAIKIN APPLIED
2
TABLE OF CONTENTS
Introduction..................................3
Hazard Identication ..........................3
General Description ..........................4
Installation...................................5
Nameplates .................................5
Inspection ..................................5
Unit Placement ..............................5
Lifting Guidance .............................6
Transit and Temporary Storage..................7
Long Term Storage ...........................7
Heat Exchanger Water Piping ...................8
Relief Valves ...............................11
Retrot Knockdown ..........................13
Templier...................................18
Source Water Piping .........................18
Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Control Circuit ..............................20
Use with On-Site Generators ..................20
Physical Data ...............................23
Operation...................................25
Control System Architecture ...................25
Operator Responsibilities .....................25
Operator Schools ...........................25
MicroTech Unit Controller Inputs/Outputs .........26
Set Points .................................27
Circuit Level Set Points .......................30
Unit Function ...............................30
Unit Enable ................................31
Unit Mode Selection .........................31
Unit Status.................................32
Evaporator Pump Control .....................32
Condenser Pump Control .....................33
Cooling Tower Control ........................34
Leaving Water Temp (LWT) Target ..............35
Unit Capacity Limits .........................36
RapidRestore Option.........................36
Circuit Functions ............................37
Circuit Status...............................38
Compressor Control .........................38
Evaporator EXV Control ......................39
Circuit Capacity Overrides ....................40
Alarms ....................................40
Clearing Alarms/Faults .......................41
Unit Alarms ................................42
Circuit Alarms ..............................44
Events ....................................48
Unit Controller Operation .....................50
Maintenance ................................52
Pre-Startup ................................52
Flow Switch Installation and Calibration ..........52
Mounting ..................................52
Startup....................................56
Temporary Shutdown ........................56
Startup After Temporary Shutdown ..............56
Extended (Seasonal) Shutdown ................56
Startup After Extended (Seasonal) Shutdown......56
General Maintenance ........................56
Vibration Monitoring (Optional) .................57
Lubrication.................................57
Electrical Terminals ..........................58
Liquid Line Sight Glass .......................58
Appendix ...................................60
Limited Product Warranty .....................60
Pre-Start Checklist ..........................61
©2024 Daikin Applied, Minneapolis, MN. All rights reserved throughout the world.This document contains the most current product information as of this
printing. Daikin Applied Americas Inc. has the right to change the information, design, and construction of the product represented within the document
without prior notice. For the most up-to-date product information, please go to www.DaikinApplied.com.
™® MicroTech, Navigator, SiteLine, VVR, and Daikin Applied are trademarks or registered trademarks of Daikin Applied Americas Inc. The following
are trademarks or registered trademarks of their respective companies: BACnet from American Society of Heating, Refrigerating and Air-Conditioning
Engineers, Inc.; Echelon, LonWorks, LonMark, and LonTalk from Echelon Corporation; Modbus from Schneider Electric; and Windows from Microsoft
Corporation.