Data Aire MINI CEILING SERIES - Monthly Maintenance Inspection Checklist

32
Data Aire, Inc.
Monthly Maintenance Inspection Checklist
Model No. __________________ Serial No. ____________________
Prepared by: _______________ Date: ___ / ___/ 200__
Air Filters
___ Check for restricted air fl ow
Blower Section
___ Blower wheel free of debris moves freely
___ Check belt tension and condition
___ Bearings in good condition
___ Check pulleys and motor mounts
Air Distribution Section
___ Check for restriction in grille(s)
Compressor
___ Check for leaks
Refrigeration Cycle/Section
___ Check crank case temperature
Air Cooled Condenser (if applicable)
___ Condenser coil clean
___ Motor Mounts tight
___ Motor fan bearings in good condition
___ Refrigeration lines properly supported
Water/Glycol Fluid Cooler (if applicable)
___ Water regulating valve function
___ Check for water/glycol leaks (piping
area)
Glycol Pump(s)
___ Glycol leaks (pump area)
___ Pump operation
___ Auto air vent clean of mineral deposits
Condensate Drain and Pump (if applicable)
___ Check for water leaks
___ Check for restricted air fl ow
___ Pump operation
Steam Generating Humidifi er
___ Check canister for deposits and water
level
___Check condition of steam hose and
clamps
Electrical Panel
___ Check contactor operation
___ DAPII control panel operations
Equipment Runtimes
Blower _________ hrs
Condenser _________ hrs
Compressor _________ hrs
Reheat _________ hrs
Humidifi er _________ hrs
Dehumidifi cation _________ hrs
Energy Saver _________ hrs
___ Reset all to read zero runtimes
Temperature/Humidity set at: ___° ___% RH
Notes: ______________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________
_____________________________________