Delfield 403 - Standard Labor Guidelines

Compact Refrigerators and Freezers Service and Installation Manual
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.del eld.com
14
Standard Labor Guidelines To Repair or Replace Parts on Delfield Equipment
Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage.
•
A maximum of 1-hour is allowed to
diagnose a defective component
.
•
A maximum of 1-hour is allowed for
retrieval of parts
not in stock.
•
A maximum
travel distance
of 100 miles round trip and 2-hours will be reimbursed.
•
Overtime, installation/start-up, normal control adjustments, general maintenance, glass breakage, freight damage, and/or
correcting and end-user installation error will not be reimbursed under warranty unless pre-approved with a
Service Work
Authorization
from Delfield. You must submit the number with the service claim.
LABOR OF 1-HOUR IS ALLOWED TO REPLACE:
•
Thermostat
•
Contractor/Relay
•
Infinite Switch
•
Transformer
•
Door Jam Switch
•
Evaporator/Condenser Fan Motor and Blade
•
Solenoid Coil
•
Circulating Fan Motor and Blade
•
Hi-limit/Thermal Protector Switch
•
Microprocessor Control
•
Fan Delay/Defrost Termination Switch
•
Water Level Sensor/Probe
•
Compressor Start Components and Overload Protector
•
Door Hinges, Locks, and Gaskets
•
Defrost Timer
•
Condensate Element
•
Thermometer
•
Springs/Lowerator
•
Gear Box
LABOR OF 2 HOURS TO REPLACE:
•
Drawer Tracks/Cartridges
•
Defrost Element
•
Pressure Control
•
Heating Element
•
Solenoid Valve
•
Locate/Repair Leak
LABOR OF 3 HOURS TO REPLACE:
•
EPR or CPR Valve
•
Condensor or Evaporator Coil
•
Expansion Valve
LABOR OF 4 HOURS TO REPLACE
•
Compressor
This includes recovery of refrigerant and leak check.
$35.00 maximum reimbursement for refrigerant recovery (includes recovery machine, pump, torch, oil, flux, minor fittings,
solder, brazing rod, nitrogen, or similar fees.)
REFRIGERANTS
•
R22 A maximum of $4.00/lb. or 25¢/oz. will be reimbursed.
•
R134A A maximum of $5.00/lb. or 31¢/oz. will be reimbursed.
•
R404A A maximum of $12.00/lb. or 75¢/oz. will be reimbursed.