Doosan C185WKU-T4I - User Manual

Questions and Answers

J
jerry25Aug 25, 2025
What to do if Doosan C185WKU-T4I unit fails to shutdown?
- M
  Melissa CarterAug 26, 2025
  If your Doosan Air Compressor unit fails to shutdown, it could be due to several reasons. A defective discharge air temperature switch, separator temperature switch, engine temperature switch, or engine oil pressure switch could be the cause; in any of these cases, replace the switch. Alternatively, a defective shutdown solenoid might be the issue; carefully block the air inlet to stop the engine. A malfunctioning relay can also cause this problem, so replace the relay. If the start switch is defective, pull the wire off the shutdown solenoid and replace the defective item. Lastly, a wire shorted hot can prevent shutdown; repair the short.
J
Jason ThomasNov 9, 2025
Why does my Doosan Air Compressor unit shutdown?
- K
  Karen MooreNov 9, 2025
  If your Doosan Air Compressor unit shuts down, several factors could be the cause. It might be due to a blown fuse, in which case you should replace the fuse and check for any shorts. Alternatively, a loose wire connection could be the culprit; inspect the wires at the switches and connector blocks, making necessary repairs. If the engine oil pressure is too low, check the engine oil level and add oil if needed. Also, check the coolant level if the engine water temperature is too high, and add coolant if necessary. If the unit is out of fuel, add CLEAN diesel fuel. Other potential causes include a malfunctioning relay (replace the relay), a defective discharge air temperature switch (replace the switch), a defective engine oil pressure switch (replace the switch), or a broken engine fan be...
K
Kenneth JohnsonNov 16, 2025
Why my Doosan Air Compressor won’t start/run?
- J
  Jonathan WaltersNov 16, 2025
  If your Doosan Air Compressor won't start or run, there are several potential causes. First, ensure that the unit has enough fuel by adding CLEAN diesel fuel. If the fuel filters are clogged, service them. Check the compressor oil level and add the correct oil if it's too low. Inspect for loose wire connections and repair or replace them as needed. Verify the battery voltage is adequate, checking both the electrolyte level and the connections. Other possible causes include a defective alternator (replace or repair), high engine water temperature (check and add fluid if necessary), a malfunctioning start switch (replace the switch), or a defective D2 diode (replace the diode). Also, check for a blown fuse and replace it, looking for any shorts. If the engine oil pressure is too low, check t...
C
charleshaydenDec 3, 2025
How to troubleshoot high compressor oil temperature in Doosan Air Compressor?